Approval Details

Valid E.O.

Validity

This Executive Order approved the specified parts on on March 26, 2003.
As of Thursday, November 28th, 2024 this Executive Order has not been overturned or superceeded.

Approved Parts

Part NumberModelsModificationRemarks
11220832061998-2001, C260, C280, C320, CLK320, SLK320, 1998-2000, E320, 1998-1999, ML320, 2002, SLK320The Kleemann Comfort Power Compressor Kit consists of an Autorotor supercharger with a pulley diameter of 87mm for the 6 cylinder engine and 75mm for the 8 cylinder engine. The factory fuel system is modified with an additional fuel pressure regulator that raises fuel rail pressure in proportion to the positive manifold pressure. The factory intake manifold is replaced with a new manifold housing that contains the supercharger and intercooler assembly. The EGR tube inside the manifold is modified to ensure even distribution of gases into each cylinder. The factory electric air injection pump is relocated to the inside fender area. Maximum boost pressure is 7 psi. The C class models receive a voltage step up device for the fuel pump when in the boost mode. A 500 ohm resistor, designed to prevent a lean condition during high RPMs, is installed inline with the output signal of the mass air flow meter.Vehicles which have been certified to a Ultra-Low-Emission Vehicle (ULEV) and/or the Supplemental Federal Test Procedure (SFTP) standards are excluded from this Executive Order.

This Executive Order may be listed as:
  • C.A.R.B.E.O. D-528-1
  • Executive Order 528-1 / D528-1
  • ARB # D-528-1
  • Executive Order No: D-528-1
  • C.A.R.B. No. D-528-1
  • Resolution D-528-1
For Free CARB Executive Order Status verification, email an image of the device Executive Order label as well as the Year/Make/Model and Test Group # of the vehicle to [email protected]

Download: Executive Order D-528-1 PDF

D-528-1 Document:

CARB_D-528-1

State of California AIR RESOURCES BOARD EXECUTIVE ORDER D—528—1 cpmitncs Relating to Exemptions Under Section 27156 . of the Vehicle Code Kleemann USA, Inc. Kleemann Comfort Power Compressor Kit Pursuant to the authority vested in the Air Resources Board by Section 27156 of the Vehicle | Code; and Pursuant to the authority vested in the undersigned by Section 39515 and Section 39516 of the Health and Safety Code and Executive Order G—02—003; T IS ORDERED AND RESOLVED: That the installation of the Kleemann Comfort Power Compressor Kit, manufactured and marketed by Kleemann USA, Inc., 2845 Ore Mill Road, # 7, Colorado Springs, Colorado 80904 has been found not to reduce the effectiveness of the applicable vehicle pollution control system and, therefore, is exempt from the prohibitions of Section 27156 of the Vehicle Code for the following 1998 through 2003 Mercedes—Benz vehicles with either a 6 or 8—cylinder engine. Part No. Model Year Models 1122083206 1998—2001 C260, C280, C320, CLK320, SLK320 &" 1998—2000 E320 1998—1999 ML320 2002 SLK320 1132085508 1998—2001 E55, CLK430, CLKS55, ML430, MLS55, S430, $55, CL55, G500, MLS500 1998—2000 E430, S500 2002 E55, ML500, CLK55 2002—2003 $55, CL55, G500, ML55 Vehicles certified to the Uitra—Low—Emission Vehicle (ULEV) and/or the Supplemental Federal Test Procedure (SFTP) standards are excluded from this Executive Order. The Kieemann Comfort Power Compressor Kit consists of an Autorotor supercharger with a pulley diameter of 87mm for the 6 cylinder engine and 75mm for the 8 cylinder engine. The . factory fuel system is modified with an additional fuel pressure regulator that raises fuel rail pressure in proportion to the positive manifold pressure. The factory intake manifold is replaced with a new manifold housing that contains the supercharger and intercooler assembly. The EGR tube inside the manifold is modified to ensure even distribution of gases into each cylinder. The factory electric air injection pump is relocated to the inside fender area. Maximum boost pressure is 7 psi. The C class models receive a voltage step up device for the fuel pump when in the boost mode. A 500 ohm resistor, designed to prevent a lean condition during high RPMs, is installed inline with the output signal of the mass air flow meter.

9. This Executive Order shall not apply to any Kieemann USA, Inc.‘s Kleemann Comfort Power Lenis.. Compressor Kit advertised, offered for sale, sold with, or installed on a new motor vehicle prior to or concurrent with transfer to an ultimate purchaser. This Executive Order is valid provided that the installation instructions for the Kleemann Comfort Power Compressor Kit will not recommend tuning the vehicle to specifications different from those of the vehicle manufacturer. Changes made to the design or operating conditions of the Kleemann Comfort Power Compressor Kit, as exempt by the Air Resources Board, which adversely affect the performance of the vehicle‘s pollution control system shall invalidate this Executive Order. Marketing of the Kleemann Comfort Power Compressor Kit using any identification other than that shown in this Executive Order or marketing of the Kleemann Comfort Power Compressor Kit for an application other than those listed in this Executive Order shall be prohibited unless prior approval is obtained from the Air Resources Board. Exemption of the Kleemann Comfort Power Compressor Kit shall not be construed as exemption to sell, offer for sale, or advertise any component of the kit as an individual device. This Executive Order does not constitute any opinion as to the effect the use of the Kileemann Comfort Power Compressor Kit may have on any warranty either expressed or implied by the vehicle manufacturer. Kleemann USA, Inc. previously submitted emissions test data (Executive Order D—528) which showed that the Kleemann Comfort Power Compressor Kit did not adversely affect tailpipe emissions during a Cold Start CVS—75 Federal Test Procedure. A 2000 Mercedes—Benz E320 with a 3.2L engine, and certified to the Low Emission Vehicle (LEV) emission standards was used as the test vehicle. Results of the emission testing with the Kleemann Comfort Power Compressor Kit installed are shown below. NMOG CO NOx HCHO Standards 0.075 3.4 0.2 0.015 Device w/idf 0.026 0.4 0. 0.001 Test results showed that the Kleemann Comfort Power Compressor Kit did not cause exhaust emissions to exceed the applicable emission standards with deterioration factors applied. This Executive Order is also based on an On—Board Diagnostic II (OBD I1) test conducted on the same vehicle. Test data showed that the Kleemann Comfort Power Compressor Kit when installed on the vehicle did not affect the vehicle‘s ability to perform its OBD 11 monitoring. The ARB finds that reasonable grounds exist to believe that use of the Kleemann Comfort Power Compressor Kit may adversely affect emissions of motor vehicles when operating under conditions outside the parameters of the Cold Start CVS—75 Federal Test Procedure. KLEEMANN USA, INC.—KLEEMANN COMFORT POWER COMPRESSOR KIT—D—528—1

—3— Accordingly, the ARB reserves the right to conduct additional emission tests, in the future, as such tests are developed, that will more adequately measure emissions from all cycle phases. |artike. If such test results demonstrate that the Kleemann Comfort Power Compressor Kit adversely affects emissions during off—cycle conditions (defined as those conditions which are beyond the parameters of the Cold Start CVS—75 Federal Test Procedure), this Executive Order shall be effectively rescinded as of the date the test results are validated. Further, if such test results or other evidence provides the ARB with reason to suspect that the Kileemann Comfort Power Compressor Kit will affect the durability of the emission control system, Kleemann USA, Inc. shall be required to submit durability data to show that the durability of the vehicle emission control system is not, in fact, affected and/or that the add—on or modified part demonstrates adequate durability. In addition to the foregoing, the ARB reserves the right in the future to review this Executive Order and the exemption provided herein to assure that the exempted add—on or modified part continues to meet the standards and procedures of Title 13, California Code of Regulations, Section 2222, et seq. THIS EXECUTIVE ORDER DOES NOT CONSTITUTE A CERTIFICATION, ACCREDITATION, APPROVAL, OR ANY OTHER TYPE OF ENDORSEMENT BY THE AIR RESOURCES BOARD OF ANY CLAIMS OF THE APPLICANT CONCERNING ANTI—POLLUTION BENEFITS OR ANY ALLEGED BENEFITS OF KLEEMANN USA, INCS KLEEMANN COMFORT POWER COMPRESSOR KIT. No claim of any kind, such as "Approved by the Air Resources Board", may be made with respect to the action taken herein in any advertising or other oral or written communication. Violation of any of the above conditions shall be grounds for revocation of this order. The order may be revoked only after a ten—day written notice of intention to revoke the order, in which period the holder of the order may request in writing a hearing to contest the proposed revocation. If a hearing is requested, it shall be held within ten days of receipt of the request and the order may not be revoked until a determination is made after the hearing that grounds for revocation exist. Executed at El Monte, California, this &fl day of March 2003. Alle%%’ons, Chief Mobile Source Operations Division KLEEMANN USA, INC.—KLEEMANN COMFORT POWER COMPRESSOR KIT—D—528—1 ~>


Document Created: 2005-09-01 12:44:01
Document Modified: 2005-09-01 12:44:01

Previous E.O. D-528 | Previous E.O. D-527 | Next E.O. D-528-2 | Next E.O. D-529