Approval Details

Valid E.O.

Validity

This Executive Order approved the specified parts on on September 29, 2008.
As of Thursday, November 28th, 2024 this Executive Order has not been overturned or superceeded.

Approved Parts

Part NumberModelsRemarks
150512004 to 2008 model year Ford 4.6L and 5.4L F-Series trucksThe Ford Evolution is a hand held programmer designed to reprogram the FLASH memory chip located in the vehicleÔÇÖs ECU module. The Ford Evolution has three main stages of enhancement: transmission only, towing, and performance. The Ford Evolution is designed to download OEM calibration updates, non emission related upgrades, and patches or fixes in the firmware. Ford Evolution data files cannot be modified by the end user.

This Executive Order may be listed as:
  • C.A.R.B.E.O. D-541-3
  • Executive Order 541-3 / D541-3
  • ARB # D-541-3
  • Executive Order No: D-541-3
  • C.A.R.B. No. D-541-3
  • Resolution D-541-3
For Free CARB Executive Order Status verification, email an image of the device Executive Order label as well as the Year/Make/Model and Test Group # of the vehicle to [email protected]

Download: Executive Order D-541-3 PDF

D-541-3 Document:

CARB_D-541-3

State of California AIR RESOURCES BOARD EXECUTIVE ORDER D—541—3 Relating to Exemptions Under Section 27156 of the California Vehicle Code Edge Products Ford Evolution, Part Number 15051 Pursuant to the authority vested in the Air Resources Board by Section 27156 of the Vehicle Code; and _Pursuant to the authority vested in the undersigned by Section 39515 and Section 39516 of the Health and Safety Code and Executlve Order G—02—003; IT IS ORDERED AND RESOLVED: That the installation of the Ford Evolution, part _ number 15051, manufactured and marketed by Edge Products, 1080 South Depot Drive, Ogden, Utah 94404, has been found not to reduce the effectiveness of the applicable vehicle pollution control systems and, therefore, is exempt from the prohibitions of Section 27156 of the Vehicle Code for 2004 to 2008 model year Ford 4.6L and 5.4L F—Series trucks. The Ford Evolution is a hand held programmer designed to reprogram the FLASH memory chip located in the vehicle‘s ECU module. The Ford Evolution has three main stages of enhancement: transmission only, towing, and performance. The Ford Evolution is designed to download OEM calibration updates, non emission related upgrades, and patches or fixes in the firmware. Ford Evolution data files cannot be modified by the end user. This Executive Order is valid provided that the installation instructions for the Ford Evolution will not recommend tuning the vehicle to specifications different from those submitted by the device manufacturer. Changes made to the design or operating conditions of the Ford Evolution, as exempt by the Air Resources Board, which adversely affect the performance of the vehicle‘s pollution control system shall invalidate this Executive Order. » This Executive Order shall not apply to any Ford Evolution advertised, offered for sale, sold with, or installed on a new motor vehicle prior to or concurrent with transfer to an ultimate purchaser. Marketing of the Ford Evolution using any identification other than that shown in this Executive Order or marketing of the Ford Evolution for an application other than those listed in this Executive Order shall be prohibited unless prior approval is obtained from the Air Resources Board. This Executive Order does not constitute any opinion as to the effect the use of the Ford Evolution may have on any warranty either expressed or implied by the vehicle manufacturer. This Executive Order is granted based on submitted emission test data generated on a 2007 model year 5.4L Ford F—150, certified to the Low Emission Vehicle II Ultra Low Emission

9. Vehicle (LEV II ULEV) emission standards and modified with the Ford Evolution. Test results showed that emission levels, with the Ford Evolution‘s performance program installed, met the applicable emission standards when tested using the Cold—Start CVS—75 Federal Test Procedure (FTP) test cycle and the Supplemental Federal Test Procedure (SFTP USO6 and SCO3) test cycle. Examination of the OBD II system showed the Ford Evolution did not affect OBD II system operation. Results from emissions testing conducted at Automotive Testing and Development Services, Inc., located in Ontario, California, are shown below (in grams per mile with deterioration factors applied). 2007 F—150 CVS—75 FTP SFTP NMOG CO NOx HCHO NMHC+NOx CO Standards, UL 0.070 2.1 0.04 0.011 1.49(composite) 13.2 (USO6) Device Test 0.052 1.2 0.03 0.001 0.05 1.9 The Air Resources Board reserves the right in the future to review this Executive Order and the exemption provided herein to assure that the exempted add—on or modified part continues to meet the standards and procedures of Title 13, California Code of Regulations, Section 2222, et seq. | THIS EXECUTIVE ORDER DOES NOT CONSTITUTE A CERTIFICATION, ACCREDITATION, APPROVAL, OR ANY OTHER TYPE OF ENDORSEMENT BY THE AIR RESOURCES BOARD OF ANY CLAIMS OF THE APPLICANT CONCERNING ANTI—POLLUTION BENEFITS OR ANY ALLEGED BENEFITS OF THE FORD EVOLUTION | Noclaim of any kind, such as "Approved by the Air Resources Board", may be made with respect to the action taken herein in any advertising or other oral or written communication. | Violation of any of the above conditions shall be grounds for revocation of this order. The order may be revoked only after a ten—day written notice of intention to revoke the order, in which period the holder of the order may request in writing a hearing to contest the proposed revocation. If a hearing is requested, it shall be held within ten days of receipt of the request and the order may not be revoked until a determination is made after the hearing that grounds for revocation exist. _— Executed at El Monte, California, this Z 7 day of September 2008. Annette Hebert, Chief Mobile Source Operations Division EDGE PRODUCTS —FORD EVOLUTION — D—541—3


Document Created: 2008-10-31 14:41:36
Document Modified: 2008-10-31 14:41:36

Previous E.O. D-541-2 | Previous E.O. D-540 | Next E.O. D-541-4 | Next E.O. D-542