Approval Details

Valid E.O.

Validity

This Executive Order approved the specified parts on on November 27, 2008.
As of Thursday, November 28th, 2024 this Executive Order has not been overturned or superceeded.

Approved Parts

ModelsRemarks
2008 and 2009 model year Victory Kingpin motorcyclesInstallation of the Trike Conversion Kit does not require the modification or relocation of any engine or emission control system component other than a relocation of one of the stock catalysts and mufflers from the right side to the left side of the vehicle (catalyst remains at a distance similar to stock) and a minor relocation of the right side catalyst and muffler (about a half inch to an inch away from the engine). The stock gas tank is retained and no additional gas tank is installed.

This Executive Order may be listed as:
  • C.A.R.B.E.O. D-611-4
  • Executive Order 611-4 / D611-4
  • ARB # D-611-4
  • Executive Order No: D-611-4
  • C.A.R.B. No. D-611-4
  • Resolution D-611-4
For Free CARB Executive Order Status verification, email an image of the device Executive Order label as well as the Year/Make/Model and Test Group # of the vehicle to [email protected]

Download: Executive Order D-611-4 PDF

D-611-4 Document:

CARB_D-611-4

State of California AIR RESOURCES BOARD EXECUTIVE ORDER D-611-4 Relating to Exemptions Under Section 27156 of the California Vehicle Code Lehman Trikes USA, Inc. Pit Boss Trike Conversion Kits Pursuant to the authority vested in the Air Resources Board by Section 27156 of the Vehicle Code; and Pursuant to the authority vested in the undersigned by Section 39515 and Section 39516 of the Health and Safety Code and Executive Order G-02-003; IT IS ORDERED AND RESOLVED: That the installation of the Pit Boss Trike Conversion Kits, produced and marketed by Lehman Trikes USA, Inc. of 125 Industrial Drive, Spearfish, South Dakota 57783, has been found not to reduce the effectiveness of the applicable vehicle pollution control systems and, therefore, is exempt from the prohibitions of Section 27156 of the Vehicle Code for the following motorcycles: Pit Boss- for 2008 and 2009 model year Victory Kingpin motorcycles. Installation of the Trike Conversion Kit does not require the modification or relocation of any engine or emission control system component other than a relocation of one of the stock catalyst and muffler from the right side to the left side of the vehicle (catalyst remains at a distance similar to stock) and a minor relocation of the right side catalyst and muffler (about a half inch to an inch away from the engine). The stock gas tank is retained and no additional gas tank is installed. This Executive Order is valid provided the installation instructions for the Pit Boss Trike Conversion Kits will not recommend tuning the vehicle to specifications different from those of the vehicle manufacturer. Changes made to the design or operating conditions of the Pit Boss Trike Conversion Kits, as exempt by the Air Resources Board, which adversely affect the performance of the vehicle's pollution control system shall invalidate this Executive Order. Marketing of the Pit Boss Trike Conversion Kits using any identification other than that shown in this Executive Order or marketing of the Pit Boss Trike Conversion Kits for an application other than those listed in this Executive Order shall be prohibited unless prior approval is obtained from the Air Resources Board. This Executive Order does not constitute any opinion as to the effect the use of the Pit Boss Trike Conversion Kits may have on any warranty either expressed or implied by the vehicle manufacturer.

2. This Executive Order is granted based on submitted emission test data generated on a 2008 model year 1.7L Victory Kingpin. Test results showed that emission levels, with _ the Pit Boss Trike Conversion Kit installed, met the applicable emission standards when tested using the Cold—Start CVS—75 Federal Test Procedure (FTP). Results from emission testing conducted at Sierra Research, located in Sacramento, California, are shown below in grams per kilometer, with deterioration factors (df) applied. CVS—75 FTP HC+NOx CO Standards 0.8 12 Device w/ df 0.6 4.9 The Air Resources Board reserves the right in the future to review this Executive Order and the exemption provided herein to assure that the exempted add—on or modified part continues to meet the standards and procedures of Title 13, California Code of Regulations, Section 2222, et seq. THIS EXECUTIVE ORDER DOES NOT CONSTITUTE A CERTIFICATION, ACCREDITATION, APPROVAL, OR ANY OTHER TYPE OF ENDORSEMENT BY THE AIR RESOURCES BOARD OF ANY CLAIMS OF THE APPLICANT CONCERNING ANTI—POLLUTION BENEFITS OR ANY ALLEGED BENEFITS OF LEHMAN TRIKES USA, INC.‘S PIT BOSS TRIKE CONVERSION KITS. No claim of any kind, such as "Approved by the Air Resources Board", may be made with respect to the action taken herein in any advertising or other oral or written communication. Violation of any of the above conditions shall be grounds for revocation of this order. The order may be revoked only after a ten—day written notice of intention to revoke the order, in which period the holder of the order may request in writing a hearing to contest the proposed revocation. If a hearing is requested, it shall be held within ten days of receipt of the request and the order may not be revoked until a determination is made after the hearing that grounds for revocation exist. Executed at El Monte, California, this _ 2 ZJ‘L" day of November 2008. %&nette Hebert, Chief Mobile Source Operations Division LEHMAN TRIKES USA, INC. — TRIKE CONVERSION KITS — D—611—4


Document Created: 2013-09-13 15:24:42
Document Modified: 2013-09-13 15:24:42

Previous E.O. D-611-3 | Previous E.O. D-610 | Next E.O. D-611-5 | Next E.O. D-612