Approval Details

Valid E.O.

Validity

This Executive Order approved the specified parts on on August 7, 2000.
As of Wednesday, August 21st, 2019 this Executive Order has not been overturned or superceeded.

Approved Parts

Part NumberModelsRemarks
50041983-93 Dodge PU D100/200/300, 2wd, carburetor, air injection, 318-360 c.i.d. engine1 5/8 primary tube dia., 16 gage mild steel construction

This Executive Order may be listed as:
  • C.A.R.B.E.O. D-164-10
  • Executive Order 164-10 / D164-10
  • ARB # D-164-10
  • Executive Order No: D-164-10
  • C.A.R.B. No. D-164-10
  • Resolution D-164-10
For Free CARB Executive Order Status verification, email an image of the device Executive Order label as well as the Year/Make/Model and Test Group # of the vehicle to [email protected]

Download: Executive Order D-164-10 PDF

D-164-10 Document:



                                                            (Page 1 of 2)


                                     State of California
                                 AIR RESOURCES BOARD



                               EXECUTIVE ORDER D—164—10
                         Relating to Exemptions Under Section 27156
                                      of the Vehicle Code


                               HOOKER INDUSTRIES, INC.
                         SUPER COMPETITION EXHAUST HEADERS


Pursuant to the authority vested in the Air Resources Board by Section 27156 of the
Vehicle Code; and

Pursuant to the authority vested in the undersigned by Section 39515 and Section
39516 of the Health and Safety Code and Executive Order G—45—9;

IT IS ORDERED AND RESOLVED: That the installation of the Super Competition
Exhaust Header System manufactured out of 0.060 inch wall thickness (16 gauge) steel
tubing by Hooker Industries, Inc. of 1024 West Brooks Street, Ontario, California 91762,
has been found not to reduce the effectiveness of required motor vehicle pollution
control devices and, therefore, is exempt from the prohibitions of Section 27156 of the
California Vehicle Code for those vehicle applications as listed in Exhibit A, which is
attached hereto and incorporated herein, excluding those vehicles certified to Ultra—
Low Emission Vehicle (ULEV) and Low Emission Vehicle (LEV) standards, or
vehicles certified with the close—coupled catalyst system.

This exemption is issued based on submitted emissions test data from an independent
laboratory which showed the Hooker Competition Header System did not adversely
affect exhaust emissions on the tested vehicle. The test results are shown below.

1999 4.0L Jeep Wrangler
                     ,                           NMOG         CO         NOX       HCHO
Device (g/mi) with df‘s applied                  0.064        0.8           0.6    0.001
Standard (g/mi)                                  0.160        4.4           0.7    0.018

This Executive Order is also based on On Board Diagnostic II (OBD I!) testing
conducted on the same vehicle. Test data showed that the Hooker Competition Header
System when installed on the vehicle did not affect the vehicle‘s ability to perform its
OBD I! monitoring.

This exemption shall not apply to any device, apparatus, or mechanism advertised,
offered for sale, sold with, or installed on a motor vehicle prior to or concurrent with
transfer to an ultimate purchaser.


HOOKER INDUSTRIES, INC.                                    EXECUTIVE ORDER D—164—10
EXHAUST HEADERS                                            (Page 2 of 2)


This Executive Order is valid provided that the installation instructions for this device will
not recommend tuning the vehicle to specifications different from those submitted by
the system manufacturer.

Changes made to the design or operating conditions of the device, as exempted by the
Air Resources Board, that adversely affect the performance of a vehicle‘s pollution
control system shall invalidate this Executive Order.

Marketing of this device using any identification other than that shown in this Executive
Order or marketing of this device for an application other than those listed in this
Executive Order shall be prohibited unless prior approval is obtained from the Air
Resources Board.

This Executive Order does not constitute any opinion as to the effect the use of this
device may have on any warranty either expressed or implied by the vehicle
manufacturer.

THIS EXECUTIVE ORDER DOES NOT CONSTITUTE A CERTIFICATION,
ACCREDITATION, APPROVAL, OR ANY OTHER TYPE OF ENDORSEMENT BY THE
AIR RESOURCES BOARD OF ANY CLAIMS OF THE APPLICANT CONCERNING
ANTI—POLLUTION BENEFITS OR ANY ALLEGED BENEFITS OF HOOKER SUPER
COMPETITION EXHAUST HEADER SYSTEMS.

No claims of any kind, such as "Approved by the Air Resources Board" may be made
with respect to the action taken herein in any advertising or other oral or written
communication.

Violation of any of the above conditions shall be grounds for revocation of this order.
The order may be revoked only after ten day written notice of intention to revoke the
order, in which period the holder of the order may request in writing a hearing to contest
the proposed revocation. If a hearing is requested, it shall be held within ten days of
receipt of the request and the order may not be revoked until a determination after
hearing that grounds for revocation exist.

Executed at El Monte, California, this    7 “J     day of August 2000.




                                         4e
                                          .   B.               mz
                                                     merfield, Chief
                                         Mobile Source Operations Division


                                                         Exhibit A


                                                                                                              Primary
  Part                                                                                                        Tube       .
  Number Years       Applications                               Notes                             Engines     ___Diameter(s) (in)
  5004|   1983—93    Dodge PU DiG0/200/300                      2WD w7 Carb/T.BI. w/ ALR.         318360      1578
  5005    1983—93    Dodge PU D100/200/300                      2WD w/ Carb/T.B.I. w/o A.LR.      318—360     15/s
 5006     1983—93    Dodge W100/200 .                           4WD w/ Carb/T.BI. w/ A.LR.        318360      15/s
                     Dodge Ramcharger                                                                '
 5007     1983—93    Dodge W100/200                             4AWD w/ Carb/T.BI. w/o ALR.       318—360     15/8s
                     Dodge Ramcharger
 5008     199295      Dodge Dakota                              2WD FL.                           52LV8       1578
 5001     1994—98    Dodge Ram PU 1500/2500                     2 & 4WD F.I.                      5.2/5.9L V8 15/s8
 5002     1994—96    Dodge Ram PU 2500                          2 & 4WD EL.                       8.0L V10    13/4
  5003    1992%—00 Dodge Viper Convertible & Coupe              FI. Side Exhaust                  8.0L V10    13/4
_ 9850    1992%—98 Jeep Grand Cherokee                          4WD F.I. (Dodge Magnum Motor)     S5.2L V8    15/8
 5011+    97—2000    Ram PU 2500 V10                            2 & 4WDFI.                        8.0L V10    13/4
 5010     97—2000    Dakota PU                                  2WD FI.                           52L V8      15/8

 9851+ — 91—99      Jeep Wrangler                               4WD                               4.0L        1il/2
 9852\   87—90      Jeep Wrangler                               4WD                               258ci       1!/2
 9853+ 87—00        Jeep Wrangler                               4wD                               25L         1!/2
 9854.    93—98     Jeep Crand Cherokee                         2/4WD                             4.0L        i1/2
 9855 +   87—98     Jeep Cherokee/Comanche                      2/4WD                             4.0L        il/2
 9856     84—8%6    Jeep Cherokee/Comanche                      2/4WD                             2.8L        11/2
 9857 +   87—98     Jeep Cherokee/Comanche                      2/4WD                             2.5L        1!/2
 8200 —    89—94    Mitsubishi Eclipse DOHC                                                       2.0L        11/21°/8
                    Plymouth Laser
                    Eagle Talon
 8201.    95—00     Mitsubishi Eclipse DOHC                                                       2.0L         11/21°/8
                    Plymouth Laser
                    Eagle Talon
 8202     95—97     Dodge Neon SOHC                                                               2.0L         11/215/38
 8203     95—97     Dodge Neon DOHC                                                               2.0L         11/215/8

                    Legend
                    2WD           :   Two Wheel Drive                T.BL.        Throttle Body Injection
                    4WD               Four Wheel Drive               ALR.         Air Injection Reactor
                    FI.               Fuel Injection                 PU           Pickup



Document Created: 2005-09-01 12:45:44
Document Modified: 2005-09-01 12:45:44

Previous E.O. D-164-9 | Previous E.O. D-163 | Next E.O. D-164-11 | Next E.O. D-165