Approval Details

Valid E.O.

Validity

This Executive Order approved the specified parts on on June 10, 2011.
As of Sunday, June 16th, 2019 this Executive Order has not been overturned or superceeded.

Approved Parts

Part NumberModelsRemarks
See PDF2005 through 2012 Ford 5.4L passenger cars.The Whipple Supercharger Kit includes a twin screw Whipple supercharger, open element air filter with intake air tubing, 123 mm diameter mass air flow sensor with stock electronics, optional fuel pump, optional single blade throttle body or 63.5 mm dual blade throttle body, and a new ECM calibration. Installation would not require any modification to any fuel or emission related tubing and the stock crankshaft pulley, coolant thermostat, and fuel injectors are retained. The Whipple supercharger is designed to be a direct bolt-on replacement to the stock supercharger. The new ECM calibration and/or programmer does not have any emission related user adjustments nor can it be capable of allowing the user to upload new fuel and timing maps.

This Executive Order may be listed as:
  • C.A.R.B.E.O. D-231-35
  • Executive Order 231-35 / D231-35
  • ARB # D-231-35
  • Executive Order No: D-231-35
  • C.A.R.B. No. D-231-35
  • Resolution D-231-35
For Free CARB Executive Order Status verification, email an image of the device Executive Order label as well as the Year/Make/Model and Test Group # of the vehicle to [email protected]

Download: Executive Order D-231-35 PDF

D-231-35 Document:



                                          State of California
                                     AIR RESOURCES BOARD

                                   EXECUTIVE ORDER D—231—35

                            Relating to Exemptions Under Section 27156
                                       of the California Vehicle Code

                                       Whipple Industries, Inc.
                                       Whipple Supercharger

 Pursuant to the authonty vested in the Air Resources Board by Section 27156 of the Vehicle
 Code; and

 Pursuant to the authority vested in the undersigned by Section 39515 and Section 39516 of the
 Health and Safety Code and Executive Order G—02—003;

 IT 18 ORDERED AND RESOLVED: That the installation of the Whipple Supercharger,
 manufactured and marketed by Whipple Industries, Inc., 3292 N. Weber, Fresno, California
 93722, has been found not to reduce the effectiveness of the applicable vehicle pollution control
 systems and, therefore, is exempt from the prohibitions of Section 27156 of the Vehicle Code for
 the Ford Motor Company 5.4L passengercars listed in Exhibit A.

 The Whipple Supercharger Kit includes a twin screw Whipple supercharger, open element air _
 filter with intake air tubing, 123 mm diameter mass air flow sensor with stock electronics, optional
 fuel pump, optional single blade throttle body or 63.5 mm dual blade throttle body, and a new
ECM calibration. Installation would not require any modification to any fuel or emission related
 tubing and the stock crankshaft pulley, coolant thermostat, and fuel injectors are retained. The
 Whipple supercharger is designed to be a direct bolt—on replacement to the stock
 supercharger. The new ECM calibration and/or programmer does not have any emission
 related user adjustments nor can it be capable of allowing the user to upload new fuel and trmlng
 maps.

 This Executive Order is valid provided that the installation instructions for the Whipple
 Supercharger will not recommend tuning the vehicle to specifications different from those
 submitted by the device manufacturer.                 —

 Changes made to the design or operating conditions of the Whipple Supercharger, as exempt by
 the Air Resources Board, which adversely affect the performance of the vehicle‘s pollution control
 system shall invalidate this Executive Order.                   —       —

 This Executive Order shall not apply to any Whrpple Supercharger advertised, offered for sale,
 sold with, or installed on a new motor vehicle prior to or concurrent with transfer to an ultimate
 purchaser.

 Marketing of the Whipple Supercharger using any identification other than that shown in this
 Executive Order or marketing ofthe Whipple Supercharger for an applicationother than those               A
 listed in this Executive Order shall be prohibited unless prior approval is obtained from the Air    _       I
 Resources Board.                                                                                         t

 This Executive Order does not constitute any opinion as to the effect the use of the Whipple
 Supercharger may have on any warranty elther expressed or implied by the vehicle
 manufacturer.


This Executive Order is granted based on previously submitted emissions and OBD 1I test data
that was generated in support of Executive Order D—231—31. The test vehicle was a 2008 model
year 5.4L Ford Mustang certified to the Low Emission Vehicle II Low Emission Vehicle emission
standards.

The Air Resources Board reserves the right in the future to review this Executive Order and the
exemption provided herein to assure that the exempted add—on or modified part continues to
meet the standards and procedures of Title 13, California Code of Regulations, Section 2222, et
seq.

THIS EXECUTIVE ORDER DOES NOT CONSTITUTE A CERTIFICATION, ACCREDITATION,
APPROVAL, OR ANY OTHER TYPE OF ENDORSEMENT BY THE AIR RESOURCES BOARD
OF ANY CLAIMS OF THE APPLICANT CONCERNING ANTI—POLLUTION BENEFITS OR ANY
ALLEGED BENEFITS OF THE WHIPPLE SUPERCHARGER.

No claim of any kind, such as "Approved by the Air Resources Board", may be made with respect
to the action taken herein in any advertising or other oral or written communication.

Violation of any of the above conditions shall be grounds for revocation of this order. The order
may be revoked only after a ten—day written notice of intention to revoke the order, in which
period the holder of the order may request in writing a hearing to contest the proposed
revocation. If a hearing is requested, it shall be held within ten days of receipt of the request and
the order may not be revoked until a determination is made after the hearing that grounds for
revocation exist.


Executed at El Monte, California, this     / O 3%‘ day of June 2011.




                                i;Aring[e%?ém
                                   t¢Mebile Source Operations Division




            WHIPPLE INDUSTRIES, INC. — WHIPPLE SUPERCHARGER — D—231—35


                                          Exhibit A



                                                                MAX                     CRANK
  YEARS               MAKE            WHIPPLE KIT    ENGINE BOOST          COMPRESSOR
                                                                                        PULLEY     SC
                                           # 0.      |(LMER)| "pof            SIZE       orze |PULEY
2005—2007|Ford GT                    WIK—5.4—4VvGT     54L        i5          3.4L       Stock 3.500
2005—2007|Ford GT                    WIK—5.4—4VvGT     5.4L       i5          3.4L       Stock 3.750
2005—2007 |Ford GT.                  WIK—5.4—4vGT      54L        i5          4.0L       Stock _|_3.250
2005—2007|Ford GT                    WIK—5.4—4vGT      54L        i5          4.0L       Stock 3.375
2005—2007 |Ford GT.                  Wik5.4—4vGT       54L        i5          4.0L       Stock_| 3.500
2005—2007 |Ford GT.                  Wik—5.4—4VGT      5.4L       i5          4.0L       Stock 3.625
2005—2007 |Ford GT.                  Wik—5.4—4VGT      54L        15.         4.0L_      Stock _|_3.750
2005—2007 |Ford GT                   Wik—5.4—4vGT      54L        i5          4.0L       Stock 3.875
2005—2007 |Ford GT.                  WiIK—5.4—4vGT     54L        i5          4.0L.      Stock_| 4.000
2007—2012 |Shelby GT500 / GTSOOKR |WK—5.4—GT500 |_     5.4L      22           2.3L       Stock_| 2.500
2007—2012 |Shelby GT500 / GTS00OKR |WkK—5.4—G1500      |_5.4L_|  22           2Z.3L _    Stock 2.625
2007—2012 |Shelby GTS00 / GTS00KR |WK—5.4—GT500        5.4L      22           2.3L       Stock 2.750
2007—2012 |Shelby GTS00 / GTS00KR |Wk—5.4—GT500        5.4L      _|__22       2.3L       Stock 2.975
2007—2012 |Shelby GTS00 / GTSOOKR |WK—5.4—GT500        5.4L      22           2Z.3L      Stock 3.000
2007—2012 |Shelby GT5S00 / GTS00KR_|WkK—5.4—G1500      5.4L      22           2.9L       Stock 2.500
2007—2012 |Sheliby GT500 / GTSO0KR_|WK—5.4—G1500       |_5.4L_|__22           2.9L       Stock 2.625
2007—2012 |Shelby GT500 / GTS00KR_|WK—5.4—G1500        5.4L      22           2.9L       Stock 2.750 |:
2007—2012 |Shelby GT500 / GTS00KR |WK—5.4—G1500        |_5.4L_|__22           2.9L.      Stock 2.875—
2007—2012 |Shelby GT500 / GTS00KR |WK—5.4—G1500        5.4L      _|__22       2.9L       Stock 3.000
2007—2012 |Shelby GT500 / GTS00KR_|WK—5.4—GT500        5.4L      _|__22       2.9L       Stock 3.125
2007—2012 |Shelby GT5S00 / GTS00KR |WK—5.4—G1500       5.4L       _|__22    ~ 2.9L       Stock 3.250
2007—2012 |Shelby GT500 / GTS00KR |Wk—5.4—G1500        5.4L      _|__22       2.9L       Stock 3.375
2007—2012 |Shelby GTS00 / GTSOOKR |WK—5.4—GT500        5.4L       |__22       2.9L       Stock_| _3.500
2007—2012 |Shelby GTS00 / aTSookr_|WK—5.4—GT500        5.4L       22          2.9L       Stock 3.625
2007—2012 |Shelby GT500 / GTS00KR_|WK—5.4—G1500        5.4L       22          3.4L       Stock 3.000
2007—2012 |Shelby GT500 / GTS00kR |WK—5.4—GI500        |_5.4L     22          3.4L       Stock 3.125
2007—2012 |Shelby GT500 / GTS00KR |WK—5.4—G1500—]      5.4L       22          3.4L       Stock 3.250
2007—2012 |Shelby GTS00 / GT500KR_|WK—5.4—G1500        5.4L       22          3.4L       Stock | 3.375
2007—2012 |Shelby GT5S00 / GT500KR_|WK—5.4—GT500       5.4L       22          3.4L       Stock 3.500
2007—2012 |Shelby GT500 / GTSO0OKR_|WK—5.4—GT500       5.4L       22          3.4L       Stock 3.625
2007—2012 |Shelby GT500 / GTS0O0KR |WK—5.4—GT500       |_5.4L_|   22          3.4L       Stock 3.750
2007—2012 |Shelby GTS00 / GT500KR_|WK—5.4—GT500        |_5.4L     22          34L        Stock 3.875
2007—2012|Shelby GT500 / GTSOOKR |WK—5.4—GT500         5.4L       22          3.4L       Stock _|_4.000
2007—2012 |Shelby GT500 / GTS0O0KR _|WK—5.4—G1500      |_5.4L__|__22          4.0L.      Stock 3.000
2007—2012 |Shelby GT500 / GTS0O0KR_|WK—5.4—GT500       5.4L       22          4.0L       Stock 3.125
2007—2012 |Shelby GT500 / GTS00KR_|WkK—5.4—GT500       5.4L |__22             4.0L.      Stock 3.250
2007—2012 |Shelby G1500 / GTSO0KR_|WK—5.4—GT500        |_5.4L_|__22           4.0L       Stock 3.375
2007—2012 |Shelby GT500 / GTSO0OKR_|WK—5.4—G1500       5.4L       _|__22      4.0L       Stock 3.500
2007—2012 Shelby G1500 / GTSO0KR |WK—5.4—G1500         |_5.4L     22.         4.0L.      Stock 3.625
2007—2012 |Shelby GT500 / GTSO0KR |WK—5.4—GT500        5.4L       22          4.0L.      Stock_| 3.750
2007—2012 |Shelby GT500 / GTIS0O0KR_|WK—5.4—GT500      5.4L       _|__22      4.0L.      Stock 3.875
2007—2012 Shelby GT500 / GT50O0KR WK—5.4—GT500         |_5.4L     22          4.0L.      Stock 4.000



Document Created: 2011-06-20 16:32:11
Document Modified: 2011-06-20 16:32:11

Previous E.O. D-231-34 | Previous E.O. D-230 | Next E.O. D-231-36 | Next E.O. D-232