Approval Details

Valid E.O.

Validity

This Executive Order approved the specified parts on on October 17, 2011.
As of Monday, October 21st, 2024 this Executive Order has not been overturned or superceeded.

Approved Parts

Part NumberModelsModification
See PDF2005 to 2012 Chrysler V8 vehicles, and 2004 to 2006 4.0L Jeep Wrangler/Cherokee (See PDF)The TS Series Supercharger Kit includes: Kenne Bell displacement twin screw supercharger, intake manifold, bypass valve, a set of high flow injectors, electronic booster for stock fuel pump, intercooler, a new air cleaner housing with an open element style filter, and a reflashed ECM. Boost is limited to 9.0 psi. The stock crankshaft pulley, throttlebody, thermostat and mass air flow sensor are retained. The tuner used to reflash the ECM is designed to download OEM calibration updates, non emissions related upgrades, and patches or fixes in the firmware. Emission-related data files cannot be modified by the end user. Breather hoses may be replaced with an SAE30R9 rated hose.

This Executive Order may be listed as:
  • C.A.R.B.E.O. D-271-22
  • Executive Order 271-22 / D271-22
  • ARB # D-271-22
  • Executive Order No: D-271-22
  • C.A.R.B. No. D-271-22
  • Resolution D-271-22
For Free CARB Executive Order Status verification, email an image of the device Executive Order label as well as the Year/Make/Model and Test Group # of the vehicle to [email protected]

Download: Executive Order D-271-22 PDF

D-271-22 Document:

CARB_D-271-22

State of California AIR RESOURCES BOARD EXECUTIVE ORDER D—271—22 Relating to Exemptions Under Section 27156 — of the California Vehicle Code Kenne Bell, Inc. TS Series Supercharger _ Pursuant to the authority vested in the Air Resources Board by Section 27156 of the Vehicle Code; and Pursuant to the authority vested in the undersigned by Section 39515 andSection 39516 of the Health and Safety Code and Executive Order G—02—003; IT IS ORDERED AND RESOLVED: That the installation of the TS Series Supercharger, manufactured and marketed by Kenne Bell, Inc., 10743 Bell Court, Rancho Cucamonga, California 91730, has been found not to reduce theeffectiveness of the applicable vehicle pollution control systems and, therefore, is exempt from the prohibitions of Section 27156 of the Vehicle Code for the following Chrysler vehicles listed in Exhibit A. The TS Series Supercharger Kit includes: Kenne Bell displacement twin screw supercharger, intake manifold, bypass valve, a set of high flow injectors, electronic booster for stock fuel pump, intercooler, a new air cleaner.housing with an open element style filter, and a reflashed ECM. Boost is limited to 9.0 psi. The stock crankshaft pulley, throttlebody, thermostat and mass air flow sensor are retained. The tuner used to reflash the ECM is designed to download OEM calibration updates, non emissions related upgrades, and patches or fixes in the firmware. Emission—related data files cannot be modified by the end user. Breather hoses may be replaced with an SAE30R9 rated hose. This Executive Order is valid provided that the installation instructions for the TS Series Supercharger will not recommend tuning the vehicle to specmcatlonsdlfferent from those _ submitted by the device manufacturer. Changes made to the design or operating conditions of the TS Series Supercharger, as exempt by the Air Resources Board, which adversely affect the performance of the vehicle‘s pollution control system shall invalidate this Executive Order. This Executive Order shall not apply to any TS Series Supercharger advertised, offered for sale, sold with, or installed on a new motor vehicle prior to or concurrent with transfer to an ultimate purchaser. Marketing of the TS Series Supercharger using any identification other than that shown in this Executive Order or marketing of the TS Series Supercharger for an application other than those listed in this Executive Order shall be prohibited unless prior approval is obtained from the Air Resources Board. . This Executive Order does not constitute any opinion as to the effect the use of the TS Series Supercharger may have on any warranty either expressed or implied by the vehicle manufacturer

This Executive Order is granted based on emission test data generated on a 2009 model year 5.7L Dodge Challenger modified with the TS Series Supercharger Kit. Test results showed that emission levels, with the supercharger kit installed, met the applicable emission standards when tested using the Cold—Start CVS—75 Federal Test Procedure (FTP) test cycle and the Supplemental Federal Test Procedure (SFTP) test cycle. Examination of the OBD II system showed that the supercharger kit did not affect OBD II system operation. Results from emission testing conducted at the Automotive Testing and Development Services, Inc., of Ontario, California are listed below (in grams per mile) with deterioration factors applied. CVS—75 FTP NMOG CO NOx HCHO Standards* 0.070 2.1 0.04 0.011 Device Test 0.062 1.2 0.02 0.001 ' USO6/SCO3 NMHC+NOx . CO Standards 4k 0.14/0.20 8.0/2.7 Device 0.05/0.04 0.86/70.7 *LEV IJ ULEV CVS—75 FTP Useful Life Emissions Standards. The Air Resources Board reserves the right in the future to review this Executive Order and the exemption provided herein to assure that the exempted add—on or modified part continues to meet the standards and procedures of Title 13, California Code of Regulations, Section 2222, et seq. THIS EXECUTIVE ORDER DOES NOT CONSTITUTE A CERTIFICATION, ACCREDITATION, APPROVAL, OR ANY OTHER TYPE OF ENDORSEMENT BY THE AIR RESOURCES BOARD OF ANY CLAIMS OF THE APPLICANT CONCERNING ANTI—POLLUTION BENEFITS OR ANY ALLEGED BENEFITS OF THE TS SERIES SUPERCHARGER. No claim of any kind, such as "Approved by the Air Resources Board", may be made with respect to the action taken herein in any advertising or other oral or written communication. Violation of any of the above conditions shall be grounds for revocation of this order. The _ order may be revoked only after a ten—day written notice of intention to revoke the order, in which period the holder of the order may request in writing a hearing to contest the proposed revocation. If a hearing is requested, it shall be held within ten days of receipt of the request and the order may not be revoked until a determination is made after the hearing that grounds for revocation exist. Executed at El Monte, California, this ___/ 7 day of October 2011. %nefie Hebert, Chief ile Source Operations Division KENNE BELL, INC. — TS SERIES SUPERCHARGER — D—271—22

EXHIBIT A Peu SERIEs TS7500—5.7) 2008—12 DODGE CHALLENGER _ 5.7 9.0 3.75 4.25 TS7500—6.1 2008—10 DODGE CHALLENGER 6.1 9.0 3.50 4.00 TS7500—6.4 2011—12 DODGE CHALLENGER 6.4 9.0 3.12 3.62 TS7500—5.7 2006—12 DODGE CHARCGER 5.7 9.0 3.75 4.25 TS7500—6.1 2006—10 DODGE CHARGER 6.1 9.0 3.50 4.00 TS7500—6.4 2011—12 DODGE CHARGER 6.4 9.0 3.12 3.62 TS7500—5.7 2005—08 DODGE MAGNUM 5.7 9.0 3.75 4.25 TS7500—6.1 2005—08 DODGE MAGNUM 6.1 9.0 3.50 4.00 TS7500—5.7 2005—12 CHRYSLER 300C 5.7 9.0 3.75 4.25 TS7500—6.1 2005—10 CHRYSLER 300C 6.1 9.0 3.50 4.00 TS7500—6.4 2011—12 CHRYSLER 300C 6.4 9.0 3.12 3.62 TS7500—5.7 2005—11 JEEP GRAND CHEROKEE 5.7 9.0 3.75 4.25 TS7500—6.1 2006—10 JEEP GRAND CHEROKEE 6.1 9.0 3.50 4.00 TS7500—6.4 2012 JEEP GRAND CHEROKEE 6.4 9.0 3. 12 3.62 TS7500—8.0 2004—08 VIPER 8.0 6.0 2.20 TS7500—4.0 2004—06 JEEP WRANGLER/CHEROKEE 4.0 6.0 2.62


Document Created: 2011-11-28 16:01:03
Document Modified: 2011-11-28 16:01:03

Previous E.O. D-271-21 | Previous E.O. D-270 | Next E.O. D-271-23 | Next E.O. D-272