Approval Details

Valid E.O.

Validity

This Executive Order approved the specified parts on on April 30, 2013.
As of Tuesday, December 11th, 2018 this Executive Order has not been overturned or superceeded.

Approved Parts

Part NumberModelsModification
see pdfsee pdfsee pdf

This Executive Order may be listed as:
  • C.A.R.B.E.O. D-271-25
  • Executive Order 271-25 / D271-25
  • ARB # D-271-25
  • Executive Order No: D-271-25
  • C.A.R.B. No. D-271-25
  • Resolution D-271-25
For Free CARB Executive Order Status verification, email an image of the device Executive Order label as well as the Year/Make/Model and Test Group # of the vehicle to [email protected]

Download: Executive Order D-271-25 PDF

D-271-25 Document:



                                          —        State of California
                                              AIR RESOURCES BOARD

                                          EXECUTIVEORDER D—271—25

                                 Relatlng to Exemptlons Under Sectlon 27156
                                            . of the Cahfornla Vehicle Code

                                                      Kenne Beill, Inc.:
                                                TS Series Supercharger

  Pursuant to the authorlty vested in the Air Resources Board by Sectlon 27156 of the Vehlcle
  Code; and

  Pursuant to the Iauthority_veété,d in ’the undérsigned by Section 39515 and Section 39516 of
  the Health and Safety Code and Executive Order G—02—003;                 .

   IT IS ORDERED AND RESOLVED: That the installation of the TS Series Supercharger,
  manufactured and marketed by Kenne Bell, Inc., 10743 Bell Court, Rancho Cucamonga,
  California 91730, has been found not to reduce the effectiveness of the applicable vehicle
  pollution control systems and, therefore, is exempt.from the prohibitions of Section 27156 of
  the Vehicle Code for the followmg Ford: Motor Company vehicles:                      —
  PART NO         .    YEAR        MAKE                     ENGINE (L)           _   BOOSsT                       SUPERCHARGER PULLEYDia.
                                                                                                                  Displacement (L) (Inches)

   TS1000 SERIES      — 2007412 SHELBY        GT5OO/KR —      5.4                      12                                    2.8                3.25
   TS1000 SERIES        2007—12    SHELBY     GT50O0/KR       5.4                      12                                 . 3.6               — 3.87 .
   TS1000 SERIES        2007—12    SHELBY     GT5OO/KR        5.4 _                    12                             ‘     —4.2           ~ _ 4.50.
   TS1000 SERIES      2013 to 2014 SHELBY     GT500/KR        5.80 °0    u0C           12                                    2.8                3.25
   TS1000 SERIES      2013 to 2014 SHELBY     GT50O0/KR:      5.8                      12                                  . 3.6        <u    = 3.87
 . TS1000 SERIES      2013 to 2014 SHELBY     GT5O0/KR        5.8                      12                                    4.2                4.50

    TS1000   SERIES 2011—2014*      MUSTANG      GT           5.0                     12              —                      2.6            —3.25
  ~ TS1000   SERIES 2011—2014*      MUSTANG      GT           5.0                     12                          j          2.8             3.75"
    TS1000   SERIES 2011—2014*      MUSTANG      GT           5.0                     12      _                              3.6             4.00"
    TS1000   SERIES 2011—2014*      MUSTANG      GT           5.0        |            12          C                        : 4.2             4.50"
    TS1000   SERIES 2005—2010*      MUSTANG      GT           4.6 .                   8                   .                  2.6.   .        4.00"
_ TS1000     SERIES 2005—2010*      MUSTANG      GT     .     4.6            .        8                       v              2.8             4.12”
 — TS1000    SERIES 2005—2010*      MUSTANG      GT           4.6                     8                                      3.6.            4.50"

  *The stock air cleaner housing is retained on 2005 model year built on or before April 30, 2005 and 2007 to 2014
  model year Mustangs.:                                                     .

  The 2007 to 2014 model year Ford Shelby GT500/KR Supercharger Kit consists of the
  following main components: Twin screwsupercharger designed to replace the stock                                                                 _
_ supercharger, modified ECM calibration, Ford GT style air intake system with—metal chrome
  tube to house the mass air flow sensor, 75 mm throttle body, and aconical air filter in a new
  air box. The‘stock crankshaft pulleyis retained. There are no changes or modificationsto
   any of the following: vacuumor emlssmn related hoses, fuel injectors, or radiator thermostat.
   Maximum boost is 12 psi.          -

   The 2011 to 2014 model year 5.0L Ford Mustang TS Series Supercharger Kit consists of
   the following main components: Twin screw supercharger, intercooler, intake manifold, —
   bypass valve, reflashed ECM, 39 pound high flow injectors, and a mass air flow sensor.
   The breather and vacuum hoses may be replaced with SAE30RY rated hose. Boost is
   limited to a maximum of 12 psi. The stock crankshaft pulley, fuel pump, air filter housmgin
   a stock orientation, and radlator thermostat are retained during installation.


The 2005 to 2010 model year 4.6L Ford Mustang TS Series Supercharger Kit consists of the
following main components: Twin screw supercharger, intercooler, intake manifold, bypass
valve, 39 pound high flow injectors, mass air flow sensor, reflashed ECM, open element air
filter on 2005 model year built after April 30, 2005 and 2006 model year Mustangs only, and
electronic fuel pump booster. The stock air cleaner housing is retained on 2005 model
year built on or before April 30, 2005, and 2007 to 2014 model year Mustangs. Air
cleaner is in a stock orientation. The breather and vacuum hoses may be replaced with an
SAE30RY rated hose. The stock crankshaft pulley and radiator thermostat are retained.

This Executive Order is valid provided that the installation instructions for the TS,Series
Supercharger will not recommend tuning the vehicle to specifications different from those
submitted by the device manufacturer.

Changes made to the design or operating conditions of the TS Series Supercharger, as
exempt by the Air Resources Board, which adversely affect the performance of the vehicle‘s
pollution control system shall invalidate this Executive Order.

This Executive Order shall not apply to any TS Series Supercharger advertised, offered for
sale, sold with, or installed on a new motor vehicle prior to or concurrent with transfer to an
ultimate purchaser

Marketing of the TS Series Supercharger using any identification other than that shown inthis
Executive Order or marketing of the TS Series Supercharger for an application other than
those listed in this Executive Order shall be prohibited unless prior approval is obtained from
the Air Resources Board.

This Executive Order does not constitute any opinion as to the effect the use of the TS Series
Supercharger may have on any warranty either expressed or implied by the vehicle
manufacturer.

This Executive Order is granted based on previously submitted emission test data from
Kenne Bell, Inc. (D—271—21 and D—271—24). The emission test results with the TS Series
Supercharger installed were below the applicable certification emission standards.
Examination of the OBD II system, showed no effect on the vehicles‘ OBD II system
operation. The same emission and OBD II test results would be expected with the TS
Series Supercharger installed on the requested vehicles.

The Air Resources Board reserves the right in the future to review this Executive Order and
the exemption provided herein to assure that the exempted add—on or modified part continues
to meet the standards and procedures of Tltle 13, California Code of Regulations, Section |
2222, et seq.

THIS EXECUTIVE ORDER DOES NOT CONSTITUTE A CERTIFICATION,      _
ACCREDITATION, APPROVAL, OR ANY OTHER TYPE OF ENDORSEMENT BY THE AIR
RESOURCES BOARD OF ANY CLAIMS OF THE APPLICANT CONCERNING
ANTI—POLLUTION BENEFITS OR ANY ALLEGED BENEFITS OF THE TS SERIES
SUPERCHARGER.

No claim of any kind, such as "Approved by the Air Resources Board", may be made with
respect to the action.taken herein in any advertising or other oral or written communication.




                KENNE BELL, INC. — TS SERIES SUPERCHARGER — D—271—25


Violation of any of the above conditions shall be grounds for revocation of this order. The
order may be revoked only after a ten—day written notice of intention to revoke the order, in
which period the holder of the order may request in writing a hearing to contest the proposed
revocation. If a hearing is requested, it shall be held within ten days of receipt of the request
and the order may not be revoked until a determination iis made after the hearing that grounds
for revocation exist.

Executed at El Monte, California, this _   33& day of April 2013.




                                      rik White, Chief
                                       obile Source Operations Division




               KENNE BELL, INC. — TS SERIES SUPERCHARGER — D—271—25.





Document Created: 2013-07-23 17:23:00
Document Modified: 2013-07-23 17:23:00

Previous E.O. D-271-24 | Previous E.O. D-270 | Next E.O. D-271-26 | Next E.O. D-272