Approval Details

Valid E.O.

Validity

This Executive Order approved the specified parts on on March 29, 2004.
As of Monday, December 10th, 2018 this Executive Order has not been overturned or superceeded.

Approved Parts

ModelsModification
1999-2004 Ford F450/F550 chassis cabs with a gross vehicle weight rating greater than 14,000 pounds (non-On-Board Diagnostic II System vehicles only)The 18-40 gallon stock tanks can be replaced with Transfer Flow, Inc.'s 30-34 gallon steel tanks.

This Executive Order may be listed as:
  • C.A.R.B.E.O. D-288-42
  • Executive Order 288-42 / D288-42
  • ARB # D-288-42
  • Executive Order No: D-288-42
  • C.A.R.B. No. D-288-42
  • Resolution D-288-42
For Free CARB Executive Order Status verification, email an image of the device Executive Order label as well as the Year/Make/Model and Test Group # of the vehicle to [email protected]

Download: Executive Order D-288-42 PDF

D-288-42 Document:



                                     State of California
                                 AIR RESOURCES BOARD

                               EXECUTIVE ORDER D—288—42

                                Relating to Exemptions under
                             Section 27156 of the Vehicle Code

                                    Transfer Flow, Inc.
                             Replacement Fuel Storage Systems

Pursuant to the authority vested in the Air Resources Board (ARB) by Section 27156 of the
Vehicle Code; and

Pursuant to the authority vested in the undersigned by Sections 39515 and 39516 of the
Health and Safety Code and Executive Order G—02—003;

IT IS ORDERED AND RESOLVED: That installation of the Replacement Fuel Storage
Systems, manufactured by Transfer Flow, Inc. (TFl) of 1444 Fortress Street, Chico, California
95973, has been found not to reduce the effectiveness of the applicable vehicle pollution
control system, and therefore, the Replacement Fuel Storage Systems are exempt from the
prohibitions in Section 27156 of the California Vehicle Code for installation on the following
Ford Motor Company vehicles with a gross vehicle weight rating greater than 14,000 pounds
(non—On—Board Diagnostic II System vehicles only):

   Model—Year       Vehicle Model                    Stock Tank        TFI Tank

   1999—2004        F450 & F550 chassis cabs         18—40 gallons     30—34 gallons

The Replacement Fuel Storage Systems include a higher capacity fuel tank, an add—on
emission canister, and low permeation fuel and vapor hoses. On chassis cabs with a
40—gallon stock tank, TFI‘s fuel tanks are smaller in capacity and do not require an add—on
emission canister.

The 2004 chassis cab systems require use of fuel and vapor hoses with permeation less
than 5 grams/m*/24 hours.

This Executive Order is based on an evaluation of the Replacement Fuel Storage Systems
for impact on the vehicles‘ evaporative emissions.

This Executive Order is valid provided that installation instructions for the Replacement Fuel
Storage Systems do not recommend tuning the vehicles to specifications different from
those of the vehicle manufacturer.

Changes made to the design or operating conditions of the Replacement Fuel Storage
Systems, as exempt by the ARB, which adversely affect the performance of the vehicle‘s
pollution control system, shall invalidate this Executive Order.

Marketing of the Replacement Fuel Storage Systems using identification other than that
shown in this Executive Order or for an application other than that listed in this Executive
Order shall be prohibited unless prior approval is obtained from the ARB.


                                               27.

Exemption of the Replacement Fuel Storage Systems shall not be construed as an
exemption to sell, offer for sale, or advertise any components of the Replacement Fuel
Storage Systems as individual devices.

This Executive Order shall not apply to any Replacement Fuel Storage Systems advertised,
offered for sale, sold with, or installed on a motor vehicle prior to or concurrent with transfer
to an ultimate purchaser.

This Executive Order does not constitute any opinion as to the effect the use of the
Replacement Fuel Storage Systems may have on any warranty either expressed or implied
by the vehicle manufacturer.

No claim of any kind, such as "Approved by the Air Resources Board," may be made with
respect to the action taken herein in any advertising or other oral or written communication.

In addition to the foregoing, the ARB reserves the right in the future to review this
Executive Order and the exemption provided herein to assure that the exempted add—on
or modified part continues to meet the standards and procedures of California Code of
Regulations, Title 13, Section 2222, et seq.

THIS EXECUTIVE ORDER DOES NOT CONSTITUTE A CERTIFICATION,
ACCREDITATION, APPROVAL, OR ANY OTHER TYPE OF ENDORSEMENT BY THE
AIR RESOURCES BOARD OF ANY CLAIMS OF THE APPLICANT CONCERNING
ANTI—POLLUTION BENEFITS OR ANY ALLEGED BENEFITS OF TRANSFER FLOW,
INC.‘S REPLACEMENT FUEL STORAGE SYSTEMS.

Violation of any of the above conditions shall be grounds for revocation of this Executive
Order. The Executive Order may be revoked only after a ten—day written notice of intention
to revoke the Executive Order, in which period the holder of the Executive Order may
request in writing a hearing to contest the proposed revocation. If a hearing is requested, it
shall be held within ten days of receipt of the request, and the Executive Order may not be
revoked until a determination is made after a hearing that grounds for revocation exist.

Executed at El Monte, California, this ZZfl'/# day of March 2004.



                                       ,/   ZL P     tz
                                      %g{ofiéhief
                                       Mobife Source Operations Division




  TRANSFER FLOW, INC. — REPLACEMENT FUEL STORAGE SYSTEMS — D—288—42



Document Created: 2005-09-01 12:39:53
Document Modified: 2005-09-01 12:39:53

Previous E.O. D-288-41 | Previous E.O. D-287 | Next E.O. D-288-43 | Next E.O. D-289