Approval Details

Valid E.O.

Validity

This Executive Order approved the specified parts on on March 23, 2015.
As of Monday, October 21st, 2019 this Executive Order has not been overturned or superceeded.

Approved Parts

Part NumberModels
See PDFSee PDF

This Executive Order may be listed as:
  • C.A.R.B.E.O. D-338-78
  • Executive Order 338-78 / D338-78
  • ARB # D-338-78
  • Executive Order No: D-338-78
  • C.A.R.B. No. D-338-78
  • Resolution D-338-78
For Free CARB Executive Order Status verification, email an image of the device Executive Order label as well as the Year/Make/Model and Test Group # of the vehicle to [email protected]

Download: Executive Order D-338-78 PDF

D-338-78 Document:



                                       State of California
                                   AIR RESOURCES BOARD

                                 EXECUTIVE ORDER D—338—78
                          Relating to Exemptions Under Section 27156
                                       of the Vehicle Code

                            Harley—Davidson Motor Company
Screamin‘ Eagle Stage IV Performance Kit and 58 mm Induction Module with Screamin‘ Eagle
                              Heavy Breather Air Cleaner Kit


Pursuant to the authority vested in the Air Resources Board (ARB) by Vehicle Code (VC)
Section 27156; and                  ©

Pursuant to the authority vested in the undersigned by Section 39515 and Section 39516 of the
Health and Safety Code and Executive Order G—14—012;

IT IS ORDERED AND RESOLVED: That the installation of the Screamin‘ Eagle Stage IV
Performance Kit and 58 mm Induction Module with Screamin‘ Eagle Heavy Breather Air Cleaner
Kit, marketed and manufactured by the Harley—Davidson Motor Company, 3700 W. Juneau
Avenue, Milwaukee, Wisconsin 53208 has been found not to reduce the effectiveness of the
applicable vehicle pollution control system and, therefore, is exempt from the prohibitions of VC
Section 27156 for 2014 and 2015 model year Harley—Davidson motorcycles with a 1200cc
engine.

The Harley—Davidson Screamin‘ Eagle Stage IV Performance Kit, part numbers 92500041 or
92500042 includes the following: 58 mm Induction Module (motorcycle throttle—body), part
number 27200026, Screamin‘ Eagle Heavy Breather Air Cleaner Kit (open element conicalfilter,
intake tube, backplate), part numbers 29400227 or 29400228, cylinder heads, pistons, camshaft
kit, and a new ECM calibration. There are no user adjustments on the new ECM calibration. No
other changes are required for proper installation.

The Harley—Davidson 58 mm Induction Module with Screamin‘ Eagle Heavy Breather Air
Cleaner Kit includes the following: 58 mim Induction Module (motorcycle throttle—body), part
number 27200026, Screamin‘ Eagle Heavy Breather Air Cleaner Kit (open element conical filter,
intake tube, backplate), part numbers 29400227 or 29400228, and a new ECM calibration.
There are no user adjustments on the new ECM calibration. No other changes are required for
proper installation.

Changes made to the design or operating conditions of the Screamin‘ Eagle Stage IV
Performance Kit and 58 mm Induction Module with Screamin‘ Eagle Heavy Breather Air Cleaner
Kit, as exempted by ARB, which adversely affect the performance of the motorcycle‘s pollution
control system shall invalidate this Executive Order.

Marketing of the Screamin‘ Eagle Stage IV Performance Kit and 58 mm Induction Module with
Screamin‘ Eagle Heavy Breather Air Cleaner Kit using any identification other than that shown in
this Executive Order or marketing of the Screamin‘ Eagle Stage IV Performance Kit and 58 mm
Induction Module with Screamin‘ Eagle Heavy Breather Air Cleaner Kit for an application other
than those listed in this Executive Order shall be prohibited unless prior approval is obtained
from the ARB.                     '


This Executive Order does not constitute any opinion as to the effect the use of these Screamin‘
Eagle Stage IV Performance Kit and 58 mm Induction Module with Screamin‘ Eagle Heavy
Breather Air Cleaner Kit may have on any warranty either expressed or implied by the
Harley—Davidson Motor Company.

Harley—Davidson submitted two sets of modified motorcycle test results: One with the Screamin‘
Eagle Stage IV Performance Kit (58 mm Induction Module and Screamin‘ Eagle Heavy Breather
Air Cleaner Kit included) and another with just the 58 mm Induction Module and Screamin‘
Eagle Heavy Breather Air Cleaner Kit. The modified motorcycles met the applicable emission
standards when tested using the Cold—Start CVS—75 Federal Test Procedure (FTP) test cycle.
Results from emissions testing conducted at the Harley—Davidson Motor Company‘s emissions
laboratory, located in Milwaukee, Wisconsin, are shown below (in grams per kilometer).

    2014 1200cc XL                                                  CVS—75 FTP
                                                                 HC+NOx          Cco
    Standards                                                     0.5          12.0

    Stage IV w/ Induction Module and Air Cleaner Kit, w/df _       0.4             1.0

    Induction Module and AirFCIeaner Kit, w/idf         '          0.3             2.2

ARB reserves the right in the future to review this Executive Order and the exemption provided
herein to assure that the exempted add—on or modified part continues to meet the standards and
procedures of Title 13, California Code of Regulations, Section 2222, et seq.

THIS EXECUTIVE ORDER DOES NOT CONSTITUTE A CERTIFICATION, ACCREDITATION,
APPROVAL, OR ANY OTHER TYPE OF ENDORSEMENT BY. THE AIR RESOURCES BOARD
OF ANY CLAIMS OF THE APPLICANT CONCERNING ANTI—POLLUTION BENEFITS OR ANY
ALLEGED BENEFITS OF HARLEY—DAVIDSON MOTOR COMPANY‘S SCREAMIN®‘ EAGLE
STAGE IV PERFORMANCE KIT AND 58 MM INDUCTION MODULE WITH SCREAMIN‘
EAGLE HEAVY BREATHER AIR CLEANER KIT.

No claim of any kind, such as "Approved by the Air Resources Board", may be made with
respect to the action taken herein in any advertising or other oral or written communication.

Violation of any of the above conditions shall be grounds for revocation of this order. The order
may be revoked only after a ten—day written notice of intention to revoke the order, in which
period the holder of the order may request in writing a hearing to contest the proposed
revocation. If a hearing is requested, it shall be held within ten days of receipt of the request
and the order may not be revoked until a determination is made after the hearing that grounds
for revocation exist.
                                            »     1z
Executed at El Monte, California, this    was ud day of March 2015.

                ——         7
                     U‘%%zwmr
                     nnéette Hebert, Chief
                       issions Compliance, Automotive Regulations and Science Division



 HARLEY—DAVIDSON MOTOR COMPANY — SCREAMIN®‘ EAGLE STAGE IV PERFORMANCE KIT
AND 58 MM INDUCTION MODULE WITH SCREAMIN®‘ EAGLE HEAVY BREATHER AIR CLEANER
                                KIT —D—338—77



Document Created: 2015-08-14 17:30:08
Document Modified: 2015-08-14 17:30:08

Previous E.O. D-338-77 | Previous E.O. D-337 | Next E.O. D-338-79 | Next E.O. D-339