Approval Details

Valid E.O.

Validity

This Executive Order approved the specified parts on on April 16, 2007.
As of Sunday, July 21st, 2019 this Executive Order has not been overturned or superceeded.

Approved Parts

Part NumberModels
10.202.501K2005 to 2007 Rabbit and Jetta with a 2.5L engine

This Executive Order may be listed as:
  • C.A.R.B.E.O. D-375-5
  • Executive Order 375-5 / D375-5
  • ARB # D-375-5
  • Executive Order No: D-375-5
  • C.A.R.B. No. D-375-5
  • Resolution D-375-5
For Free CARB Executive Order Status verification, email an image of the device Executive Order label as well as the Year/Make/Model and Test Group # of the vehicle to [email protected]

Download: Executive Order D-375-5 PDF

D-375-5 Document:



                                        State of California
                                   AIR RESOURCES BOARD

                                 EXECUTIVE ORDER D—375—5

                         Relating to Exemptions Under Section 27156
                                      of the Vehicle Code

                               Autotech Sport Tuning Corporation
                                       Cold Air Intake Kit


Pursuant to the authority vested in the Air Resources Board by Section 27156 of the Vehicle
Code; and

Pursuant to the authority vested in the undersigned by Section 39515 and Section 39516 of
the Health and Safety Code and Executive Order G—02—003;

IT IS ORDERED AND RESOLVED: That the installation of the Cold Air Intake Kit,
manufactured and marketed by Autotech Sport Tuning Corporation has been found not to
reduce the effectiveness of the applicable vehicle pollution control system and, therefore, is
exempt from the prohibitions of Section 27156 of the Vehicle Code for the following 1993
through 2007 model year Volkswagen vehicles:

Part No.     Application
10.202.501K  2005 to 2007 Rabbit and Jetta with a 2.5L engine
10.202.3011K 1993 to 1995 Golf and Jetta with a 4 cylinder engine
10.202.3012K 1996 to 1998 Golf and Jetta with a 4 cylinder engine
10.202.3021K 1993 to 1995 Golf and Jetta with a 2.8L VR6 engine
10.202.3022K 1996 to 1999 Golf and Jetta with a 2.3L VR6 engine
10.202.401K  2000 to 2005 Golf and Jetta with a 1.8L turbo engine
10.202.402K      1999 to 2003 Golf and Jetta with a 2.8L VR6 engine and 12 vaives
10.202.403K      1999 to 2005 Golf and Jetta with a 2.0L
10.202.404K      2002 to 2005 Golf and Jetta with a 2.8L VR6 engine and 24 valves

The Cold Air Intake Kit includes the following main components: open—element reusable air
filter, intake tubing, and assorted brackets and hardware. Installation requires the removal of
the stock air box and on some applications intake tubing before the throttlebody. The new air
intake is installed in place of the stock air box. No other modifications are required for
installation. Any breather lines originally attached to the stock air box are reinstalled on
Autotech‘s intake tube.

This Executive Order is valid provided that the installation instructions for the Cold Air Intake
Kit, will not recommend tuning the vehicle to specifications different from those of the vehicle
manufacturer.

Changes made to the design or operating conditions of the Cold Air Intake Kit, as exempt by
the Air Resources Board, which affect the performance of the vehicle‘s pollution control
system shall invalidate this Executive Order.

This Executive Order shall not apply to any Autotech Sport Tuning Corporation‘s Cold Air
Intake Kit, advertised, offered for sale, sold with, or installed on a new motor vehicle prior to
or concurrent with transfer to an ultimate purchaser.

Marketing of the Cold Air Intake Kit, using any identification other than that shown in this
Executive Order or marketing of the Cold Air Intake Kit, for an application other than those
listed in this Executive Order shall be prohibited unless prior approval is obtained from the Air


 Resources Board. Exemption of the Cold Air Intake Kit, shall not be construed as exemption
 to sell, offer for sale, or advertise any component of the kit as an individual device.

  This Executive Order does not constitute any opinion as to the effect the use of the
  Cold Air Intake Kit, may have on any warranty either expressed or implied by the vehicle
— manufacturer.                                                      '

 This Executive Order is granted based on submitted emissions test data generated on a
 2005 model year Volkswagen Jetta 2.5L (test group 5VWXVO2.5257), certified to the Low
 Emission Vehicle II Super Ultra Low Emission Vehicle (SULEV) emission standards with the _
 Cold Air Intake Kit installed. Testing consisted of a Cold—Start CVS—75 Federal Test
 Procedure (FTP) and the Supplemental Federal Test Procedure (SFTP USO6) test cycles.
 Results are in grams per mile with assigned deterioration factors added to
 CVS—75 FTP results. Emission levels of the modified vehicle met the applicable emission
 standards.
                              CVS—75 FTP                          USO6
                    NMOG CO         NOx    HCHO              NMHC+NOx       CO
 Standards          0.010 1.0       0.02    0.004              0.14         8.0
 w/ Device          0.007 0.3       0.00   0.000               0.02         0.5
 This Executive Order is also based on an On—Board Diagnostic II (OBD II) test conducted on
 the same test vehicle. Test data showed that the Cold Air Intake Kit, when installed on the
 vehicle did not affect the ability to perform OBD II monitoring.

 The Air Resources Board reserves the right in the future to review this Executive Order and _
 the exemption provided herein to assure that the exempted add—on or modified part
 continues to meet the standards and procedures of Title 13, California Code of Regulations,
 Section 2222, et seq.

 THIS EXECUTIVE ORDER DOES NOT CONSTITUTE A CERTIFICATION,
 ACCREDITATION, APPROVAL, OR ANY OTHER TYPE OF ENDORSEMENT BY THE AIR
 RESOURCES BOARD OF ANY CLAIMS OF THE APPLICANT CONCERNING
 ANTI—POLLUTION BENEFITS OR ANY ALLEGED BENEFITS OF AUTOTECH SPORT
 TUNING CORPORATION‘S COLD AIR INTAKE KIT.

 No claim of any kind, such as "Approved by the Air Resources Board", may be made with °
 respect to the action taken herein in any advertising or other oral or written communication.

 Violation of any of the above conditions shall be grounds for revocation of this order. The
 order may be revoked only after a ten—day written notice of intention to revoke the order, in
 which period the holder of the order may request in writing a hearing to contest the proposed
 revocation. If a hearing is requested, it shall be held within ten days of receipt of the request
 and the order may not be revoked until a determination is made after the hearing that
 grounds for revocation exist.

 Executed at El Monte, California, this    [é     day of April 2007




                                        nette Hebert, Chief
                                     Mobile Source Operations Division

       AUTOTECH SPORT TUNING CORPORATION— COLD AIR INTAKE KIT — D—375—5



Document Created: 2007-04-16 15:26:36
Document Modified: 2007-04-16 15:26:36

Previous E.O. D-375-4 | Previous E.O. D-374 | Next E.O. D-375-6 | Next E.O. D-376