Approval Details

Valid E.O.

Validity

This Executive Order approved the specified parts on on February 7, 2011.
As of Friday, October 11th, 2024 this Executive Order has not been overturned or superceeded.

Approved Parts

Part NumberModelsModification
PTR03-211012011Scion tCThe TRD Performance Air Intake Kit includes a modified air filter housing lid with a stock hydrocarbon trap that is permanently heat staked to the lid of the housing, an add-on ram air at stock inlet duct, and air intake tubing from the new air filter housing lid to the stock throttlebody. No other modifications are required for installation other than the replacement of the stock air filter housing lid, and intake tubing with Toyota Racing DevelopmentÔÇÖs unit.

This Executive Order may be listed as:
  • C.A.R.B.E.O. D-425-42
  • Executive Order 425-42 / D425-42
  • ARB # D-425-42
  • Executive Order No: D-425-42
  • C.A.R.B. No. D-425-42
  • Resolution D-425-42
For Free CARB Executive Order Status verification, email an image of the device Executive Order label as well as the Year/Make/Model and Test Group # of the vehicle to [email protected]

Download: Executive Order D-425-42 PDF

D-425-42 Document:

CARB_D-425-42

State of California AIR RESOURCES BOARD — EXECUTIVE ORDER D—425-42 ' Relating to Exemptions Under Section 27156 ofthe California Vehicle Code Toyota Racing Development _ TRD Performance Air Intake Kit . Pursuant to the authority vestedin the Air Resources Board by Section 271 56 of the Vehicle Code; and — . Pursuant to the authorrty vested in the undersigned by Section 39515 and Section 39516of the Health and Safety Code and Executive Order G—02—003 —ITIS ORDERED AND RESOLVED: That the installation of the TRD Performance Alr Intake Kit, manufactured and marketed by Toyota Rating Development, 19001 South Western. Avenue, Torrance, California 90501, has been found not to reduce the effectiveness of the applicable vehicle pollution control systems and, therefore, is exempt from the prohlbrtlons of Sectron 27156 of the Vehicle Code for the followmg vehicle applrcatrons ' EgiNLm_tfi — Vehicle Make . PTRO3—21101 ~20118cion tC PTRO3—5211 0 2008 to 2012 Scion XB The TRD Performance Air Intake Kit lncludes a modlfred air filter housing lid with a stock hydrocarbontrap that is permanently heat staked to the lid of the housing; an add—on ram air at stock inlet duct, and air intake tubing from the new air filter housing lid to the stock throttlebody. No other modifications are required for installation other than the replacement of the stock air filter housing Iid and intake tubing with Toyota Racing Development‘s unit. Thrs Executrve Order is valld provided that the lnstallatron instructions for the TRD Performance Air Intake Kit will not recommend tuning the vehlcle to specrfrcatlons dlfferent . from those submltted by the dewce manufacturer Changes made to the design or operating conditions of the TRD Performance Air Intake Krt as exempt by the Air Resources Board, which adversely affect the performance of the _ vehicle‘spollution control system shall invalidate this Executive Order. This Executive Order shall not apply to any TRD Performance.‘Air Intake Kit advertised, offered for sale, sold with, or installed on a new motor vehlcle prlor to or concurrent with transfer toan ultimate purchaser. — Marketing of the TRD Performance Air Intake Kit using any identification other than that shown in this Executive Order or marketing of the TRD Performance Air Intake Kit for an apphcatlon other than those listed in this Executive Order shall be prohibited unless prror ‘ approvalis obtalned from the Air Resources Board ' Thrs Executrve Order does not constitute any opinion as to the effect the use ofthe TRD Performance Air Intake Kit may have on any warranty either expressed or rmplled by the vehrcle manufacturer

—3_ This Executive Order is granted based on prior submitted emission test results in the modified configuration using the Cold—Start CVS—75 Federal Test Procedure, Supplemental Federal Test Procedure (USO6), and an examination of the On—Board Diagnostic II (OBDII) system. A 2008 model year Toyota xB with a 2.4 liter engine (8TYXVO2.4BEB) and a 2007 model year Toyota Tundra with a 5.7 liter engine (7ZTYXTO5.7BEV), both certified to the Low Emission Vehicle II Ultra Low Emission Vehicle (LEV II ULEV) emission standards, were used for the evaluation of the TRD Performance Air Intake Kit. Results from emissions testing conducted at Quantum Technologies, Lake Forest, California, are shown below (in grams per mile with deterioration factors applied): xB CVS—75 USO6 NMOG CO NOx HCHO NMHC+NOx CO Standards, 50k 0.040 1.7 0.05 0.008 0.14 8.0 Device Test 0.029 0.3 0.02 0.000 _ 0.03 2.1 Tundra CVS—75 USO6 ‘ NMOG CO NOx— HCHO NMHC+NOx CO Standards, 50k 0.040 1.7 0.05 0.008 0.60 11.8 Device Test 0.018 0.2 0.02 0.000 0.02 0.1 The emission test results in the modified configuration were below the applicable certification standards. Examination of the OBD II system showed the TRD Performance Air Intake Kit does not affect OBD II system operation. The Air Resources Board reserves the right in the future to review this Executive Order _ and the exemption provided herein to assure that the exempted add—on or modified part continuesto meet the standards and procedures of Title 13, Cahfornla Code of Regulations, Section2222, et seq. THIS EXECUTIVE ORDER DOES NOT CONSTITUTE A CERTIFICATION, ACCREDITATION, APPROVAL, OR ANY OTHER TYPE OF ENDORSEMENT BY THE AIR RESOURCES BOARD OF ANY CLAIMS OF THE APPLICANT CONCERNING ANTI—POLLUTION BENEFITS OR ANY ALLEGED BENEFITS OF THE TRD PERFORMANCE AIR INTAKE KIT. No claim of any kind, such as "Approved by the Air Resources Board", may be made with respect to the action taken herein in any advertising or other oral or written communication. Violation of any of the above conditions shall be grounds for revocation ofthis order. The order may be revoked only after a ten—day written notice of intention to revoke the order, in which period the holder of the order may request in writing a hearing to contest the proposed revocation. If a hearing is requested, it shall be held within ten days of receipt of the request and the order may not be revoked until a determination is made after the hearing that grounds for revocation exist. Executed at El Monte, California, this 7 day of February 2011. | Annette HebertChlef Mobile Source Operations Division TOYOTA RACING DEVELOPMENT — TRD PERFORMANCE AIR INTAKE KIT — D—425—42


Document Created: 2018-10-06 10:03:55
Document Modified: 2018-10-06 10:03:55

Previous E.O. D-425-41 | Previous E.O. D-424 | Next E.O. D-425-43 | Next E.O. D-426