Approval Details

Valid E.O.

Validity

This Executive Order approved the specified parts on on June 20, 2011.
As of Monday, June 17th, 2019 this Executive Order has not been overturned or superceeded.

Approved Parts

Part NumberModelsRemarks
See PDF2007 to 2011 model year Harley-Davidson Touring, Softail, and Dyna motorcycle models equipped with a 96 cubic inch engineThe 103 Cubic Inch Performance Kit includes the following main components: New ECU calibration (p/n 103-1CA), a Harley-Davidson Screamin Eagle Air Filter Kit (p/n 29440-990 / 29441-99A), Harley-Davidson Screamin Eagle 251 Camshaft Kit (p/n 25466-00), and a Harley-Davidson Cylinder Kit (16546-99 / 16549-99). The new ECU calibration is downloaded to the motorcycleÔÇÖs ECU and can only be installed by a dealer. The new ECU calibration has no dealer or user adjustments.

This Executive Order may be listed as:
  • C.A.R.B.E.O. D-427-16
  • Executive Order 427-16 / D427-16
  • ARB # D-427-16
  • Executive Order No: D-427-16
  • C.A.R.B. No. D-427-16
  • Resolution D-427-16
For Free CARB Executive Order Status verification, email an image of the device Executive Order label as well as the Year/Make/Model and Test Group # of the vehicle to [email protected]

Download: Executive Order D-427-16 PDF

D-427-16 Document:



                                          State of California
                                     AIR RESOURCES BOARD

                                   EXECUTIVE ORDER D—427—16

                            Relating to Exemptions Under Section 27156
                                       of the California Vehicle Code —

                          Northern California Diagnostic Laboratories, Inc.
                                   103 Cubic Inch Performance Kit

 .Pursuant to the authority vested in the Air Resources Board by Section 27156 of the Vehicle
  Code; and
        1
  Pursuant to the authority vested in the undersigned by Section 39515 and Section 39516 of
 the Health and Safety Code and Executive Order G—02—003;

  IT IS ORDERED AND RESOLVED: That the installation of the 103 Cubic Inch Performance
  Kit, produced and marketed by Northern California Diagnostic Laboratories, Inc. of 2748
 Jefferson Street, Napa, California 94558, has been found not to reduce.the effectiveness of the
   _applicable vehicle pollution control systems and, therefore, is exempt from the prohibitions of
_ Section 27156 of the Vehicle Code for 2007 to 2011 model year Harley—Davidson Touring,
 — Softail, and Dyna motorcycle models equipped with a 96 cubic inch engine.

 The 103 Cubic Inch Performance Kit includes the following main components: New ECU
 calibration (p/n 103—1,CA), a Harley—Davidson Screamin Eagle Air Filter Kit (p/n 29440—990 /
 29441—99A), Harley—Davidson Screamin Eagle 251 Camshaft Kit (p/n 25466—00);, and a Harley—
 Davidson Cylinder Kit (16546—99 / 16549—99). The new ECUcalibration is downloaded to the
  motorcycle‘s ECU and can only be installed by a dealer. The new ECU calibration has no
  dealer or user adjustments.

 Thié Executive Order is valid provi)ded the installation instructions for the 103 Cubic Inch
 Performance Kit will not recommend tuning the vehicle to specnflcatlons different from those of
 the vehicle manufacturer.

  Changes made to the design or operating conditions of the 103 Cubic Inch Performance Kit, as
  exempt by the Air Resources Board, which adversely affect the performance of thevehicle‘s
  pollution control system shall invalidate this Executive Order.

 Marketing of the 103 Cubic Inch Performance Kit using any identification other than that shown
 in this Executive Order or marketing of the 103 Cubic Inch Performance Kit for an application
 other than those listed in this Executive Order shall be prohibited unless prior approval is
 obtained from the Air Resources Board.

  This Executive Order does not constitute any obdinion as to the effect the use of the 103 Cubic
  Inch Performance Kit may have on any warranty either expressed or lmplled by the vehicle
  manufacturer.                    —


 This Executive Order is granted based on prior submitted emission test data generated on a
 2009 model year Harley—Davidson Touring model with engine family 9HDXC1.68AED. Test
 results showed that emission levels, with the 103 Cubic Inch Performance Kit installed, met the
 applicable emission standards when tested using the Cold—Start CVS—75 Federal Test
 Procedure (FTP). Results from emission testing conducted at Northern California Diagnostic
 Laboratories, Inc., located in Napa, California, are shown below in grams per kilometer, with
 deterioration factors (df) applied.

                             CVS—75       FTP
                        .__HC+NOx         CO
     Standards             0.5            12
     Device w/ df          0.3            5.5

  The Air Resources Board reserves the right in the future to review this Executive Order and the
. exemption provided herein to assure that the exempted add—on or modified part continues to
  meet the standards and procedures of Title 13, California Code of Regulations, Section 2222,
 et seq.

 THIS EXECUTIVE ORDER DOES NOT CONSTITUTE A CERTIFICATION,
 ACCREDITATION, APPROVAL, OR ANY OTHER TYPE OF ENDORSEMENT BY THE AIR
 RESOURCES BOARD OF ANY CLAIMS OF THE APPLICANT CONCERNING
 ANTI—POLLUTION BENEFITS OR ANY ALLEGED BENEFITS OF NORTHERN CALIFORNIA
 DIAGNOSTIC LABORATORIES, INC.‘S 103 CUBIC INCH PERFORMANCE KIT.

 No claim of any kind, such as "Approved by the Air Resources Board", may be made with
 respect to the action taken herein in any advertising or other oral or written communication.

 Violation of any of the above conditions shall be grounds for revocation of this order. The
 order may be revoked only after a ten—day written notice of intention to revoke the order, in
 which period the holder of the order may request in writing a hearing to contest the proposed
 revocation. If a hearing is requested, it shall be held within ten days of receipt of the request
 and the order may not be revoked until a determination is made after the hearing that grounds
 for revocation exist.

 Executed at El Monte, California, this    2@        day of June 2011.




                               ~ Annefte Hebert, Chief
                                 Mobile Source Operations Division




              NCDL, INC. — 103 CUBIC INCH PERFORMANCE KIT — D—427—16



Document Created: 2011-07-20 16:31:10
Document Modified: 2011-07-20 16:31:10

Previous E.O. D-427-15 | Previous E.O. D-426 | Next E.O. D-427-17 | Next E.O. D-428