Approval Details

Valid E.O.

Validity

This Executive Order approved the specified parts on on November 21, 2013.
As of Monday, October 7th, 2024 this Executive Order has not been overturned or superceeded.

Approved Parts

Part Number
see pdf

This Executive Order may be listed as:
  • C.A.R.B.E.O. D-488-27
  • Executive Order 488-27 / D488-27
  • ARB # D-488-27
  • Executive Order No: D-488-27
  • C.A.R.B. No. D-488-27
  • Resolution D-488-27
For Free CARB Executive Order Status verification, email an image of the device Executive Order label as well as the Year/Make/Model and Test Group # of the vehicle to [email protected]

Download: Executive Order D-488-27 PDF

D-488-27 Document:

CARB_D-488-27

State of California AIR RESOURCES BOARD EXECUTIVE:ORDER D—488—27 Relating to Exemptions Under Section 27156 — of the Vehicle Code Magnuson Products Inc. Magnuson Products I.F.D./F.I.F.D; Supercharger Kit Pursuant to the authority vestedin the Air Resources Board by Section 27156 of the Vehicle Code; and — Pursuant to the authority vested in the undersigned by Section 39515 and Section 395186 of the Health and Safety Code and Executive Order G—02—003; IT IS ORDERED AND RESOLVED: That the installation of the Magnuson Products L.F.D./F.1.F.D. Supercharger Kit manufactured and marketed by Magnuson Products Inc. . of 1990 Knoll Drive, Ventura, California 93003 has been found not to reduce the effectiveness of required motor vehicle pollution control devices and, therefore, is exempt from the prohibitions of Section 27156 of the California Vehicle Code for the General Motors Corporation vehicle applications listed in Exhibit A. The Magnuson Products |.F.D./F.1.F.D. Supercharger Kit includes the following main components: Eaton supercharger and intake manifold plenum, larger fuel injectors, new air intake filter element and tube assembly (the tube for the 2010—2013 Corvette models contains replacement hydrocarbon adsorber pads equivalent to stock), air—to—water intercooler, and new fuel and timing map calibrations. A longer intake air temperature harness is used in conjunction with the relocated sensor on the supercharger manifold (2010—2013 Corvette model!s only), and the stock fuel pump is complemented with a voltage booster (2010 Corvette and 2007 CTS—V models only). All other emission— related components are in the stock location relative to the throttle body. The F.I.F.D. systems are directly driven from the inlet side rather than from engine‘s Jackshaft as is done with the I.F.D. systems. All crankshaft pulleys are stock and maximum boost is limited to 7 psi. This Executivé Order shall not apply to anyMagnuson’ Producits I.F.D./F .1.F.D. Supercharger Kit advertised, offered for sale, sold with, or installed on a new motor vehicle prior to or concurrent with transfer to an ultimate purchaser. This Executlve Order is valid provnded that the lnstalla‘uon mstructlons for the Magnuson Products 1.F.D./F.1.F.D. Supercharger Kit will not recommend tuning the vehlcle to specifications different from those of the vehicle manufacturer. Changes made to the design or'bperating cohditions of the device, as exempted by the Air Resources Board, that adversely affect the performance of a vehicle‘s pollution control system shall invalidate this Executive Order.

2. Marketing of this device using any identification other than that shown in this Executive Order or marketing of this device for an application other than those listed in this Executive Order shall be prohibited unless prior approval is obtained from the Air Resources Board. This Executive Order does not constitute any opinion as to the effect that the use of this device may have on any warranty either expressed or implied by the vehicle manufacturer. This exemption is issued based on previously submitted emissions test data from an independent laboratory on a 2008 model year General Motors Corporation Corvette vehicle (Test Group 8GMXVO6.20868) certified to the Low Emission Vehicle I1 Uitra Low Emission Vehicle (LEV II ULEV) and Supplemental Federal Test Procedure (SFTP) standards. The exhaust emission measurements from the 2008 model year Corvette are as follows: Federal Test Procedure: NMOG CO NOX Standards* (g/mi) 0.070 2.1 0.04 Device (g/mi) with df‘s applied 0.051 1.5 0.03 SFTP (USO6 Cycle): NMHC+NOX CO Standards (g/mi) 0.14 8.0 — Device (g/mi) 0.06 1.5 SFTP (SC03 Alternative AC2 Cycle): NMHC+NOX CO Standards (g/mi) 0.20 2.7 Device (g/mi) 0.04 1.8 *USEPA Bin 4, Counted as LEV II ULEV, CVS—75 FTP emissions standards, useful Iife.v The test results show that the Magnuson Products 1.F.D./F.1.F.D. Supercharger Kit when installed on a representative vehicle will not likely cause exhaust emissions to exceed the applicable emission standards during the Cold—Start Federal Test Procedure or SFTP cycles. This Executive Order is also based on specific On—Board Diagnostic II (OBD I1) testing conducted on the modified test vehicle. The Magnuson Products |.F.D./F.IL.F.D. Supercharger Kit when installed on the test vehicle did not affect the vehicle‘s ability to perform its OBD II monitoring. In addition, the Air Resources Board reserves the right in the future to review this Executive Order and the exemption provided herein to assure that the exempted add—on or modified part continues to meet the standards and procedures of Title 13, California Code of Regulations, Section 2222, et seq. MAGNUSON PRODUCTS INC. — MAGNUSON PRODUCTS I.F.D/F.1.F.D. SUPERCHARGER KIT — D—488—27

THIS EXECUTIVE ORDER DOES NOT CONSTITUTE A CERTIFICATION, ACCREDITATION, APPROVAL, OR ANY OTHER TYPE OF ENDORSEMENT BY THE AIR RESOURCES BOARD OF ANY CLAIMS OF THE APPLICANT CONCERNING ANTI—POLLUTION BENEFITS OR ANY ALLEGED BENEFITS OF THE MAGNUSON PRODUCTS |.F.D. SUPERCHARGER KIT. No claims of any kind, such as "Approved by the Air Resources Board" may be made with respect to the action taken herein in any advertising or other oral or written communication. Violation of any of the above conditions shall be grounds for revocation of this order. The order may be revoked only after a ten day written notice of intention to revoke the order, in which period the holder of the order may request in writing a hearing to contest the proposed revocation. If a hearing is requested, it shall be held within ten days of receipt of the request and the order may not be revoked until a determmatlonis made after the hearing that grounds for revocation exist. . sF ‘ | Executed at El Monte, California, this 2/ day of November 2013. rik White, Chief Mobile Source Operations Division MAGNUSON PRODUCTS INC. — MAGNUSON PRODUCTS |.F.D/F.1.F.D. SUPERCHARGER KIT — D—488—27


EXHIBIT A E.O # D—488—27 Year Make Model Current Kit Part Number Heartbeat Kit Part Number IFD FIFD ' .2008—2013 Chevrolet Corvette 6.2 01—10—58—065—BL. 01—23—62—265—BL LEV2 / ULEV 01—10—58—065—CH 3.3 01—23—62—265—CH 3.8 01—10—58—065—PO 01—23—62—265—PO * 2008—2011 Chevrolet Corvette 6.2 01—10—58—061—SL 01—23—62—265—BL LEV2 / ULEV _ ‘ 01—10—58—061—PO 3.4 01—23—62—265—CH 3.8 01—10—58—063—SL * 01—23—62—265—PO * 01—10—58—063—PO 2008—2011 Chevrolet Corvette 6.2 01—10—58—067—BL 01—23—62—265—BL LEV2 / ULEV 01—10—58—067—CH 3.3 01—23—62—265—CH 3.8 01—10—58—067—PO 01—23—62—265—PO 2006—2013 Chevrolet Corvette 7.0 01—10—58—083—BL 01—23—62—283—BL L LEV2/LEV 01—10—58—083—CH 3.2 01—23—62—283—CH .3.7 , 01—10—58—083—PO —01—23—62—283—PO 2006—2011 Chevrolet Corvette 7.0 01—10—58—085—BL 01—23—62—283—BL LEV2 / LEV ' 01—10—58—085—CH 3.2 01—23—62—283—CH 3.7 01—10—58—085—P0O 01—23—62—283—PO 2010—2014 Chevrolet Camaro 6.2 ©01—19—60—171—BL 2.¢ n/a n/a LEV2 / ULEV 01—19—60—171—CH " nia LEV2 / LEV 01—19—60—173—BL 3.¢ nia n/a 01—19—60—173—CH ° na 01—23—60—171—BL 3.¢ 01—23—62—371—BL ‘4.8 01—23—60—111—CH * 01—23—62—371—CH ° 2010—2014 Chevrolet Camaro 6.2 01—23—60—173—BL 3.¢ 01—23—62—371—BL 3.8 01—23—60—173—CH ‘ 01—23—62—371—CH _ * 2014 Chevrolet Camaro 7.0 01—10—58—083—BL 01—23—62—283—BL LEV2 / LEV 01—10—58—083—CH 3.2 . 01—23—62—283—CH 3.7. 01—10—58—083—PO 01—23—62—283—PO 2007 Cadillac CTS 6.0 01—12—60—121—BL 2.8 n/a n/a — 01—12—60—121—CH " n/a 01—22—60—121—BL 3 n/a n/a 01—22—60—121—CH n/a 01—19—60—121—BL 3.3 n/a ~ n/ia 01—19—60—121—CH " n/a 01—23—60—121—BL 3.3 n/a n/a 01—23—60—121—CH ° n/a 2012—2013 Cadillac CTS 6.2 n/a 01—23—62—323—BL LEV2 / LEV n/a n/ia _ 01—23—62—323—CH 3.8 n/a 01—23—62—323—PO 2009—2010 Pontiac GSCGXP 6.2 01—19—60—155—BL 3.3 n/a nia 01—19—60—155—CH " nia 01—23—60—155—BL 33 n/a n/a 01—23—60—155—CH ° nia 2009—2010 Pontiac GS8 6.0 01—19—60—151—BL 3.3 n/a nia ‘01—19—80—151—CH ‘ na 01—19—60—153—BL 3.3 n/a n/a 01—19—60—153—CH " n/ia j 01—23—60—151—BL. 3.3 nia nia 01—23—60—151—CH ° nia 01—23—60—173—BL 3.3 nia nia 01—23—60—173—CH * nia



Document Created: 2014-01-28 16:47:09
Document Modified: 2014-01-28 16:47:09

Previous E.O. D-488-26 | Previous E.O. D-487 | Next E.O. D-488-28 | Next E.O. D-489