Approval Details

Valid E.O.

Validity

This Executive Order approved the specified parts on on October 2, 2000.
As of Monday, December 30th, 2024 this Executive Order has not been overturned or superceeded.

Approved Parts

Part NumberModels
7.3 Liter Engine Upgrade1992-1999 Mercedes Benz S600

This Executive Order may be listed as:
  • C.A.R.B.E.O. D-502-1
  • Executive Order 502-1 / D502-1
  • ARB # D-502-1
  • Executive Order No: D-502-1
  • C.A.R.B. No. D-502-1
  • Resolution D-502-1
For Free CARB Executive Order Status verification, email an image of the device Executive Order label as well as the Year/Make/Model and Test Group # of the vehicle to [email protected]

Download: Executive Order D-502-1 PDF

D-502-1 Document:

CARB_D-502-1

(Page 1 of 3) State of California AIR RESOURCES BOARD . EXECUTIVE ORDER D—502—1 ‘Relating to Exemptions Under Section 27156 of the Vehicle Code BRABUS NORTH AMERICA, INC. BRABUS 7.3 LITER ENGINE UPGRADE Pursuant to the authority vested in the Air Resources Board by Section 27156 of the Vehicle Code; and Pursuant to the authority vested in the undersigned by Section 39515 and Section 39516 of the Health and Safety Code and Executive Order G—45—9; IT IS ORDERED AND RESOLVED: That the installation of the Brabus 7.3 Liter Engine Upgrade, produced and marketed by Brabus North America, Inc., 4040 Campus Drive, Newport Beach, California 92660, has been found not to reduce the effectiveness of the applicable vehicle pollution control systems and, therefore, is exempt from the prohibitions of Section 27156 of the Vehicle Code for the Mercedes Benz 1992—1999 S$600, and 1992—2001 SL600. The Brabus 7.3 Liter Engine Upgrade consists of a bored engine block, polished cylinder heads, pistons, connecting rods, crankshaft, camshafts, vaive springs, and recalibrated engine control unit. This Executive Order is valid provided that the installation instructions for the Brabus 7.3 Liter Engine Upgrade will not recommend tuning the vehicle to specifications different from those of the vehicle manufacturer. Changes made to the design or operating conditions of the Brabus 7.3 Liter Engine Upgrade, as exempt by the Air Resources Board, which adversely affect the performance of the vehiclie‘s pollution control system shall invalidate this Executive Order. This Executive Order shall not apply to any Brabus 7.3 Liter Engine Upgrade advertised, offered for sale, sold with, or installed on, a motor vehicle prior to or concurrent with transfer to an ultimate purchaser.

BRABUS NORTH AMERICA, INC. . EXECUTIVE ORDERD—502—1 BRABUS 7.3 LITER ENGINE UPGRADE (Page 2 of 3) Marketing of the Brabus 7.3 Liter Engine Upgrade using any identification other than ‘that shown in this Executive Order or marketing of the Brabus 7.3 Liter Engine Upgrade for an application other than those listed in this Executive Order shall be prohibited unless prior approval is obtained from the Air Resources Board. This Executive Order does not constitute any opinion as to the effect the use of the Brabus 7.3 Liter Engine Upgrade may have on any warranty either expressed or implied by the vehicle manufacturer. This Executive Order is granted based on emission test results in the modified configuration using the Cold—Start CVS—75 Federal Test Procedure and examination of the On—Board Diagnostic II (OBD II) system. A 1999 model—year Mercedes Benz SL600 with a 6.0L fuel injected engine (XMBXVO6.0GNU, Tier—1, PC) was used for the evaluation of the Brabus 7.3 Liter Engine Upgrade. Results from emissions testing conducted at California Environmental Engineering are shown below (in grams per mile): 50k NMHC CO NOx Emission Level 0.096 11232 0.067 (w. DF applied) STD 0.25 3.4 0.4 100k NMHC CO NOx Emission Level 0.096 1.267 0.067 (w. DF applied) STD 0.31 4,.2 n/a The emission test results in the modified configuration were below the applicable certification standards with the deterioration factors applied. Examination of the OBD !I system showed the Brabus 7.3 Liter Engine Upgrade does not affect OBD II operation. Therefore, based on the test results, the staff concludes that the Brabus 7.3 Liter Engine Upgrade meets the criteria for exempting general criteria parts. However, the ARB finds that reasonable grounds exist to believe that use of the Brabus 7.3 Liter Engine Upgrade may adversely affect emissions of motor vehicles when operating under conditions outside the parameters of the CVS—75 Federal Test Procedure. Accordingly, the ARB reserves the right to conduct additional emission tests, in the future, as such tests are developed, that will more adequately measure emissions from all cycle phases. If such test results demonstrate that the Brabus 7.3 Liter Engine Upgrade adversely affects emissions during off—cycle conditions (defined as those conditions which are beyond the parameters of the Cold—Start CVS—75 Federal Test Procedure), this Executive Order shall be effectively rescinded as of the date the test N

BRABUS NORTH AMERICA, INC. ._ EXECUTIVE ORDER D—502—1 BRABUS 7.3 LITER ENGINE UPGRADE (Page 3 of 3) results are validated. Further, if such test results or other evidence provides the ARB with reason to suspect that the Brabus 7.3 Liter Engine Upgrade will affect the durability of the emission control system, Brabus North America shall be required to submit durability data to show that the durability of the vehicle emission control system is not, in fact, affected and/or that the add—on or modified part demonstrates adequate durability. In addition to the foregoing, the ARB reserves the right in the future to review this Executive Order and the exemption provided herein to assure that the exempted add—on or modified part continues to meet the standards and procedures of Title 13, California Code of Regulations, Section 2222, et seq. THIS EXECUTIVE ORDER DOES NOT CONSTITUTE A CERTIFICATION, ACCREDITATION, APPROVAL, OR ANY OTHER TYPE OF ENDORSEMENT BY THE AIR RESOURCES BOARD OF ANY CLAIMS OF THE APPLICANT CONCERNING ANTI—POLLUTION BENEFITS OR ANY ALLEGED BENEFITS OF BRABUS NORTH AMERICA, INC.‘S BRABUS 7.3 LITER ENGINE UPGRADE. No claim of any kind, such as "Approved by the Air Resources Board", may be made with respect to the action taken herein in any advertising or other oral or written communication. - Violation of any of the above conditions shall be grounds for revocation of this order. The order may be revoked only after a ten—day written notice of intention to revoke the order, in which period the holder of the order may request in writing a hearing to contest the proposed revocation. If a hearing is requested, it shall be held within ten days of receipt of the request and the order may not be revoked until a determination after hearing that grounds for revocation exist. Executed at Ei Monte, California, this _7z day of October 2000. R. B. SUM Mobile Source Operations Division


Document Created: 2005-09-01 12:44:36
Document Modified: 2005-09-01 12:44:36

Previous E.O. D-502 | Previous E.O. D-501 | Next E.O. D-502-2 | Next E.O. D-503