Approval Details

Valid E.O.

Validity

This Executive Order approved the specified parts on on August 23, 2000.
As of Monday, December 30th, 2024 this Executive Order has not been overturned or superceeded.

Approved Parts

Part NumberModelsRemarks
FX 150 461997-2000 Ford F-150, Expedition4.6 liter

This Executive Order may be listed as:
  • C.A.R.B.E.O. D-505
  • Executive Order 505 / D505
  • ARB # D-505
  • Executive Order No: D-505
  • C.A.R.B. No. D-505
  • Resolution D-505
For Free CARB Executive Order Status verification, email an image of the device Executive Order label as well as the Year/Make/Model and Test Group # of the vehicle to [email protected]

Download: Executive Order D-505 PDF

D-505 Document:

CARB_D-505

(Page 1 of 3) State of Califorhia AIR RESOURCES BOARD EXECUTIVE ORDER D—505 Relating to Exemptions Under Section 27156 of the Vehicle Code _BURTIN CORPORATION OMAX AIR INTAKE SYSTEM Pursuant to the authority vested in the Air Resources Board by Section 27156 of the Vehicle Code; and ' Pursuant to the authority vested in the undersigned by Section 39515 and Section 39516 of the Health and Safety Code and Executive Order G—45—9; IT IS ORDERED AND RESOLVED: That the installation of the Omax Air Intake System, designed by DJ Motorsports (D—458—1) and marketed by Burtin Corporation, 2550 S. Garnsey Street, Santa Ana, California 92707, has been found not to reduce the effectiveness of the applicable vehicle pollution control system and, therefore, is exempt from the prohibitions of Section 27156 of the Vehicle Code for the Ford and GM vehicles listed in Exhibit A. The Omax Air Intake System includes the following main components: open—element . reusable air filter, intake system tubing, assorted brackets, and hardware. This Executive Order is valid provided that the installation instructions for the Omax Air _ | Intake System will not recommend tuning the vehicle to specifications different from those of the vehicle manufacturer. Changes made to the design or operating conditions of the Omax Air Intake System, as exempt by the Air Resources Board, which adversely affect the performance of the vehicle‘s pollution control system shall invalidate this Executive Order. This Executive Order shall not apply to any Omax Air Intake System advertised, offered for sale, sold with, or installed on, a motor vehicle prior to or concurrent with transfer to an ultimate purchaser. Marketing of the Omax Air Intake System using any identification other than that shown in this Executive Order or marketing of the Omax Air Intake System for an application other than those listed in this Executive Order shall be prohibited unless prior approval is obtained from the Air Resources Board.

BURTIN CORPORATION EXECUTIVE ORDER D—505 OMAX AIR INTAKE SYSTEM . (Page 2 of 3) This Executive Order does not constitute any opinion as to the effect the use of the Omax Air Intake System may have on any warranty either expressed or implied by the vehicle manufacturer. This Executive Order is granted based on an examination of the On—Board Diagnostic 1i (OBD—!1) system of the vehicle in the modified configuration, and an engineering evaluation of the emissions impact of the device if measured using the Cold—Start CVS— 75 Federal Test Procedure. However, the ARB finds that reasonable grounds exist to believe that use of the Omax Air Intake System systems may adversely affect emissions of motor vehicles when operating under conditions outside the parameters of the CVS—75 Federal Test Procedure. Accordingly, the ARB reserves the right to conduct additional emission tests, in the future, as such tests are developed, that will more adequately measure emissions from all cycle phases. If such test results demonstrate that the Omax Air Intake System adversely affect emissions during off—cycle conditions (defined as those conditions which are beyond the parameters of the Cold—Start CVS—75 Federal Test Procedure), this Executive Order shall be effectively rescinded as of the date the test results are validated. Further, if such test results or other evidence provides the ARB with reason to suspect that the Omax Air Intake System will affect the durability of emission control systems, Burtin Corporation shall be required to submit durability data to show that the durability of vehicle emission control systems are not, in fact, affected and/or that the add—on or modified part demonstrates adequate durability. In addition to the foregoing, the ARB reserves the right in the future to review this Executive Order and the exemption provided herein to assure that the exempted add—on or modified part continues to meet the standards and procedures of Title 13, California Code of Regulations, Section 2222, et seq. THIS EXECUTIVE ORDER DOES NOT CONSTITUTE A CERTIFICATION, ACCREDITATION, APPROVAL, OR ANY OTHER TYPE OF ENDORSEMENT BY THE AIR RESOURCES BOARD OF ANY OTHER CLAIMS OF THE APPLICANT CONCERNING ANTI—POLLUTION BENEFITS OR ANY ALLEGED BENEFITS OF BURTIN CORPORATION‘S OMAX AIR INTAKE SYSTEM. No claim of any kind, such as "Approved by the Air Resources Board", may be made with respect to the action taken herein in any advertising or other oral or written communication.

BURTIN CORPORATION EXECUTIVE ORDER D—505 OMAX AIR INTAKE SYSTEM | — (Page 3 of 3) Violation of any of the above conditions shall be grounds for revocation of this order. The order may be revoked only after a ten—day written notice of intention to revoke the order, in which period the holder of the order may request in writing a hearing to contest . the proposed revocation. If a hearing is requested, it shall be held within ten days of receipt of the request and the order may not be revoked until a determination after hearing that grounds for revocation exist. Executed at El Montse, California, this % day of August 2000. 4 ~R. B. Summerfield, Chief Mobile Source Operations Division

Exhibit A MY MFR DISP MODEL Burtin 0 Max P/N 1997—2000 Ford 4.6 liter F—150, Expedition FX 150 46 1997—2000 Ford 5.4 liter F—150, Expedition FX 150 54 1998—1999 Ford 5.4 liter Navigator FX 150 54 1999—2000 GM 5.3 liter Siverado, Sierra CX 150 53 1999—2000 GM 4.8 liter Siverado, Sierra CX 150 48


Document Created: 2005-09-01 12:41:04
Document Modified: 2005-09-01 12:41:04

| Previous E.O. D-504 | Next E.O. D-505-1 | Next E.O. D-506