Approval Details

Valid E.O.

Validity

This Executive Order approved the specified parts on on September 19, 2012.
As of Wednesday, December 12th, 2018 this Executive Order has not been overturned or superceeded.

Approved Parts

ModelsModification
1994-2006 diesel engines with displacements up to 12 liters and horsepower ratings from 100 to 400, excluding all engines originally equipped with an aftertreatment emission control system such as a diesel oxidation catalyst or a diesel particulate filterThis exmeption is only valid provided the engines meet the following operating conditions: (1) the engine exhaust temperature is above 260 degrees Celsius for at least 30 percent of the typical duty cycle and (2) the engine is operated using ultra low sulfur diesel with a maximum sulfur content of 15 parts per million by weight or biodiesel blends containing no more than 20 percent biodiesel by volume.

This Executive Order may be listed as:
  • C.A.R.B.E.O. D-535-18
  • Executive Order 535-18 / D535-18
  • ARB # D-535-18
  • Executive Order No: D-535-18
  • C.A.R.B. No. D-535-18
  • Resolution D-535-18
For Free CARB Executive Order Status verification, email an image of the device Executive Order label as well as the Year/Make/Model and Test Group # of the vehicle to [email protected]

Download: Executive Order D-535-18 PDF

D-535-18 Document:



                                     State of California
                                 AIR RESOURCES BOARD

                              EXECUTIVE ORDER D-535-18

                               Relating to Exemptions under
                             Section 27156 of the Vehicle Code

                            Cleaire Advanced Emission Controls
                            LongMile-S Diesel Particulate Filter

Pursuant to the authority vested in the Air Resources Board by Section 27156 of the
Vehicle Code; and·

Pursuant to the authority vested in the undersigned by Sections 39515 and 39516 of the
Health and Safety Code and Executive Order G-02-003;

IT IS ORDERED AND RESOLVED: That installation of the Long Mile-S diesel particulate
filter, manufactured by Cleaire Advanced Emission Controls of 7 485 Trade Street, San
Diego, California 92121, has been found not to reduce the effectiveness of the applicable
engine emission control system, and therefore, the LongMile-S diesel particulate filter is
exempt from the prohibitions in Section 27156 of the Vehicle Code for installation on
on-road heavy-duty vehicles equipped with 1994 through 2006 model-year diesel engines
with displacements up to 12 liters and horsepower ratings from 100 to 400. This
Executive Order excludes all engines originally equipped with an aftertreatment emission
control system such as a diesel oxidation catalyst or a diesel particulate filter.

The LongMile-S diesel particulate filter consists of a metallic diesel oxidation catalyst, an
uncatalyzed silicon carbide filter, a pressure sensor, exhaust temperature sensors, and
an electronic controller. Major components of the Long Mile-S diesel particulate filter are
identified in Attachment A.

This Executive Order is only valid provided the engines meet the following operating
conditions: (1) the engine exhaust temperature is above 260 degrees Celsius for at
least 30 percent of the typical duty cycle and (2) the engine is operated using ultra low
sulfur diesel with a maximum sulfur content of 15 parts per million by weight or biodiesel
blends containing no more than 20 percent biodiesel by volume.                       ·

This Executive Order is based on emission testing Cleaire Advanced Emission Controls
conducted with the LongMile-S diesel particulate filter.

This Executive Order is valid provided that installation instructions for the Long Mile-S
diesel particulate filter do not recommend tuning the engines to specifications different
from those of the engine manufacturer:

Changes made to the design or operating conditions of the Long Mile-S diesel
particulate filter, as exempted by the Air Resources Board, which adversely affect the
performance of the engine's pollution control system, shall invalidate this Executive
Order:


                                            .       -2-

 Marketing of the Long Mile-S diesel particulate filter using identification other than that
 shown in this Executive Order or for an application other than that listed in this
 Executive Order shall be prohibited unless prior approval is obtained from the Air
 Resources Board.

 This Executive Order shall not apply to any LongMile-S diesel particulate filter
 advertised, offered for sale, sold with, or installed on a motor vehicle or an engine prior
 to or concurrent with transfer to an ultimate purchaser.

 This Executive Order does not constitute any opinion as to the effect the use of the
 Long Mile-S diesel particulate filter may have on any warranty either expressed or
 implied by the engine manufacturer.

  No claim of any kind, such as "Approved by the Air Resources Board," may be made
  with respect to the action taken herein in any advertising or other oral or written
. communication.

 In addition to the foregoing, the Air Resources Board reserves the right in the future to
 review this Executive Order and the exemption provided herein to assure that the
 exempted add-on or modified part continues to meet the standards and procedures of
 California Code of Regulations, Title 13, Section 2222, et seq.     ·

 THIS EXECUTIVE ORDER DOES NOT CONSTITUTE A CERTIFICATION,
 ACCREDITATION, APPROVAL, OR ANY OTHER TYPE OF ENDORSEMENT BY THE
 AIR RESOURCES BOARD OF ANY CLAIMS OF THE APPLICANT CONCERNING
 ANTI-POLLUTION BENEFITS OR ANY ALLEGED BENEFITS OF CLEAIRE
 ADVANCED EMISSION CONTROLS' LONGMILE-S DIESEL PARTICULATE FILTER.

 Violation of any of the above conditions shall be grounds for revocation of this Executive
 Order. The Executive Order may be revoked only after a ten-day written notice of
 intention to revoke the Executive Order, in which period the holder of the Executive
 Order may request in writing a hearing to contest the proposed revocation. If a hearing
 is requested, it shall be held within ten days of receipt of the request, and the Executive
 Order may not be revoked until a determination is made after a hearing that grounds for
 revocation exist.

 Executed at El Monte, California, this         (   C[    day of September 2012.




                                          Annette Hebert, Chief
                                          Mobile Source Operations Division




                    CLEAIRE ADVANCED EMISSION CONTROLS
                LONGMILE-S DIESEL PARTICULATE FILTER- D-535-18


                                          Attachment A

                                                                              '



                             LongMile-S Diesel Particulate Filter

                               Part                      Qty        Part Number
                        Silicon Carbide
    1
                    Diesel Particulate Filter
                                                         1                 -
                                                                    C- F-- -
                                                                  CJD-27-1 0,
                                                                 CJDA-27-1 0,
    2              Diesel Oxidation Catalyst             1
                                                                 CJD-20-10, or.
                                                                  CJDA-20-1 0
                             MLC                                CMKC-5.0- or
    3                                                    1
                  (Monitor Logger Controller)                    CMKC-6.0

    4               Backpressure Sensor                  1           CUE-45
                      I


    5                     Thermocouple                   2            CMA-4


Definition:

1. Silicon Carbide Diesel Particulate Filter:
   C<size>F-<filer supplier>-<varies with configuration> where:
   Size:
   J = 10.5" X 12"
        =
   K 11.25" X 12"
   N = 12" X 12"
   P = 13.5" X 12"
   Filter supplier:
         =
   1xx lbiden
   2xx = Liqtech
   3xx = TYK

2. Diesel Oxidation Catalyst:
              =
   CJDA uses integrated internal ring

        Application          DPF Size      DOC Size
        100-250 hp            10.5"x12"     7.5"x5"
                              10.5x12",
        250-300 hp                          10.4"x4"
                           . 11.25"x12"
        300-400 hp             12"x12"      10.4"x4"

3. Monitor Logger Controller:
   CMKC-<version><varies with configuration>




               .  CLEAIRE ADVANCED EMISSION CONTROLS
              LONGMILE-S DIESEL PARTICULATE FILTER- D-535-18



Document Created: 2012-09-27 12:18:04
Document Modified: 2012-09-27 12:18:04

Previous E.O. D-535-17 | Previous E.O. D-534 | Next E.O. D-535-19 | Next E.O. D-536