Approval Details

Valid E.O.

Validity

This Executive Order approved the specified parts on on September 8, 2017.
As of Saturday, October 12th, 2024 this Executive Order has not been overturned or superceeded.

Approved Parts

Part NumberModelsModification
See PDFSee PDFVarious Nissan vehicles (See PDF)

This Executive Order may be listed as:
  • C.A.R.B.E.O. D-550-25
  • Executive Order 550-25 / D550-25
  • ARB # D-550-25
  • Executive Order No: D-550-25
  • C.A.R.B. No. D-550-25
  • Resolution D-550-25
For Free CARB Executive Order Status verification, email an image of the device Executive Order label as well as the Year/Make/Model and Test Group # of the vehicle to [email protected]

Download: Executive Order D-550-25 PDF

D-550-25 Document:

CARB_D-550-25

State of California AIR RESOURCES BOARD EXECUTIVE ORDER D—550—25 Relating to Exemptions Under Section 27156 of the California Vehicle Code Advanced Flow Engineering, Inc. Momentum GT and Magnum Force Stage 2 Intake Systems Pursuant to the authority vested in the Air Resources Board (ARB) by Section 27156 of the Vehicle Code (VC); and Pursuant to the authority vested in the undersigned by Section 39515 and Section 39516 of the Health and Safety Code and Executive Order G—14—012; IT IS ORDERED AND RESOLVED: That the installation of the Momentum GT and Magnum Force Stage 2 intake systems, manufactured and marketed by Advanced Flow Engineering, Inc. (AFE) of 252 Granite Street, Corona, California 92879, has been found not to reduce the effectiveness of the applicable vehicle pollution control systems and, therefore, is exempt from the prohibitions of Section 27156 of the Vehicle Code for the 2004 to 2017 Nissan vehicles listed in Exhibit A. The Momentum GT and Magnum Force Stage 2 intake systems replace the stock air filter housing and tubing, and consist of the following main components: open element air filter, air intake tubing from the throttle body to the filter, air filter housing, and all necessary mounting hardware for proper installation. The PCV and crankcase breather hose may be replaced or modified with an SAE30RT rated hose or an equivalent Nissan replacement. No changes are made to any other components of the stock engine, including engine calibration. This Executive Orderis valid provided that installation instructions for the Momentum GT and Magnum Force Stage 2 intake systems will not recommend tuning the vehicle to specifications different from those of the vehicle manufacturer. Changes made to the design or operating conditions of the Momentum GT and Magnum Force Stage 2 intake systems, as exempt by the ARB, which adversely affect the performance of the vehicle‘s pollution control system shall invalidate this Executive Order. This Executive Order shall not apply to any Momentum GT and Magnum Force Stage 2 intake systems advertised, offered for sale, sold with, or installed on a new motor vehicle prior to or concurrent with transfer to an ultimate purchaser. Marketing of the Momentum GT and Magnum Force Stage 2 intake systems using any identification other than that shown in this Executive Order or marketing of the Momentum GT and Magnum Force Stage 2 intake systems for an application other than

those listed in this Executive Order shall be prohibited unless prior approval is obtained from the ARB. This Executive Order does not constitute any opinion as to the effect the use of the Momentum GT and Magnum Force Stage 2 intake systems may have on any warranty either expressed or implied by the vehicle manufacturer. This Executive Order is granted based on emission test results in the modified configuration using the Federal Test Procedure, Supplemental Federal Test Procedure (USO6), and an On—Board Diagnostics II examination. Results from emissions testing, conducted on a 2014 Nissan Frontier (ENSXT04.0G6A, LEV II ULEV) modified with the Momentum GT intake system, at SEMA Emissions Compliance Center in Diamond Bar, CA are shown below (in grams per mile): 2014 Nissan Frontier 4.0L FTP 50,000 mi. NMOG CO NOx HCHO Emission Level (DF applied) 0.031 0.5 0.02. 0.001 STD 0.040 1.7 0.05 0.008 120,000 mi. Emission Level (DF applied) 0.032 0.5 0.03 0.001 STD 0.055 2.1 0.07 0.011 USo6 NMHC + NOx CO Emission Level 0.04 1.9 STD 0.25 10.5 Emission test results in the modified configuration were below the applicable certification standards and an examination of the OBD II system showed the Momentum GT and Magnum Force Stage 2 intake systems do not affect OBD II operation. Therefore, based on the test results and a prior evaluation (D—550—16), the staff concludes that the Momentum GT and Magnum Force Stage 2 intake systems meet the criteria for exemption. ARB reserves the right in the future to review this Executive Order and the exemption provided herein to assure that the exempted add—on or modified part continues to meet the standards and procedures of Title 13, California Code of Regulations, Section 2222, et seq. Further, if test results or other evidence provides the ARB with reason to suspect that the Momentum GT and Magnum Force Stage 2 intake systems will affect the durability of emission control systems, AFE shall be required to submit durability data to show that the durability of vehicle emission control systems are not, in fact, affected and/or that the add—on or modified part demonstrates adequate durability. Advanced Flow Engineering, Inc. — Momentum GT & Magnum Force Stage 2 Intake Systems — D—550—25

THIS EXECUTIVE ORDER DOES NOT CONSTITUTE A CERTIFICATION, ACCREDITATION, APPROVAL, OR ANY OTHER TYPE OF ENDORSEMENT BY THE AIR RESOURCES BOARD OF ANY CLAIMS OF THE APPLICANT CONCERNING ANTI—POLLUTION BENEFITS OR ANY ALLEGED BENEFITS OF THE AFE MOMENTUM GT AND MAGNUM FORCE STAGE 2 INTAKE SYSTEMS. No claim of any kind, such as "Approved by the Air Resources Board", may be made with respect to the action taken herein in any advertising or other oral or written communication. Violation of any of the above conditions shall be grounds for revocation of this order. The order may be revoked only after a ten—day written notice of intention to revoke the order, in which period the holder of the order may request in writing a hearing to contest the proposed revocation. If a hearing is requested, it shall be held within ten days of receipt of the request and the order may not be revoked until a determination is made after the hearing that grounds for revocation exist. Executed at El Monte, California, this S day of September 2017. Annette Hebert, Chief Emissions Compliance, Automotive Regulations and Science Division Advanced Flow Engineering, Inc. — Momentum GT & Magnum Force Stage 2 Intake Systems — D—550—25

Exhibit A Part # Model Year Make Model* Engine 2004—2013 Infiniti QxX56 54—10312—1, 2004—15 Titan 51—10312—1, 5.6L V8 Gas 75—10312—1 2005—15 Nissan Armada 2004 Pathfinder Armada 2005—2016 Frontier 54—10492, 51—10492, 2005—12 Nissan Pathfinder 4.OL V6 Gas 75—10492 2005—15 Xterra 54—76101, . ; 51—76101 2004—2015 Nissan Titan 5.6L V8 Gas 54—76102, . . 51—76102 2005—2016 Nissan Frontier 4.0L V6 Gas 2010—2015, 2017 Nissan Armada 54—76103, 51—76103, 2011—2013 QX56 75—76103 Infiniti 2014—2017 Qx80 5.6L V8 Gas 54—76104, 2014—2017 Infiniti Qx80 51—76104, 75—76104 2010—2015 Nissan Armada *Model may include various trim levels (i.e. 2WD, 4WD, AWD etc.) Advanced Flow Engineering, Inc. — Momentum GT & Magnum Force Stage 2 Intake Systems — D—550—25


Document Created: 2017-10-16 16:59:04
Document Modified: 2017-10-16 16:59:04

Previous E.O. D-550-24 | Previous E.O. D-549 | Next E.O. D-550-26 | Next E.O. D-551