Approval Details

Valid E.O.

Validity

This Executive Order approved the specified parts on on May 20, 2015.
As of Thursday, November 28th, 2024 this Executive Order has not been overturned or superceeded.

Approved Parts

Part NumberModelsModification
FFS-9093-TVS-CA1990-1993 Mazda MX-5 Miata with 1.6L engineThe Fast Forward Supercharger Kit includes the following main components: Magnuson TVS900 supercharger with a 65 mm diameter pulley, 115 mm diameter crankshaft pulley, intake manifold with an additional fuel injector, Power Inc. throttle body, open element style air filter, and Jackson Racing PowerCard Pro (no user adjustments). Maximum boost is 10 psi. Supplied fuel hose is manufactured and labeled to SAE J30R9 standards. All other emission related components are in the stock location relative to the throttle body.

This Executive Order may be listed as:
  • C.A.R.B.E.O. D-617-2
  • Executive Order 617-2 / D617-2
  • ARB # D-617-2
  • Executive Order No: D-617-2
  • C.A.R.B. No. D-617-2
  • Resolution D-617-2
For Free CARB Executive Order Status verification, email an image of the device Executive Order label as well as the Year/Make/Model and Test Group # of the vehicle to [email protected]

Download: Executive Order D-617-2 PDF

D-617-2 Document:

CARB_D-617-2

State of Calfornia AIR RESOURCES BOARD: EXECUTIVE ORDER D—617—2 Relating to Exemptions UnderSection 27156 of the Vehicle Code KnackToys, LC Fast Forward Supercharger Kit Pursuant to the authority vested in the Air Resources Board by Section 27158 of the Vehicle Code; and Pursuant to the authority vested in the undersigned by Section 39515 and Section 39516 of the Health and Safety Code and Executive Order G—14—012; IT Is ORDERED AND RESOLVED: That the installation of the Fast Forward Supercharger Kit manufactured and marketed by KnackToys, LLC of 1217 W. Central Avenue, Coolidge, AZ 85128 has been found not to reduce the effectiveness of required motor vehicle pollution control devices and, therefore, is exempt from the prohibitions of Section 27156 of the California Vehicle Code for the Mazda vehicle models listed below Kit Number Model Year Vehicle Model Engine Size FFS—0093—TVS—CA 1990—1993 MX—5 Miata 1.6L FFS—9497—TVS—CA 1994—1997 MX—5 Miata 181 FFS—9900—TVS—CA 1999—2000 MX—5 Miata 18L FFS—0103—TVS—CA 2001—2003 MX—5 Miata 18L The Fast Forward Supercharger Kit includes the following main components Magnuson TVS200 supercharger with a 65 mm diameter pulley, 115 mm diameter crankshaft pulley, intake manifold with an additional fuel njector, Power Products throttle body, open element style air fer, and Jackson Racing PowerCard Pro (no user adjustments). Supplied fuel hose is manufactured and labeled to SAE JSORO standards. All other emission—related components are in the stock location relative to the throttle body. Maximum boost is limited to 10 psi This Executive Order shall not apply to any Fast Forward Supercharger Kit advertised offered for sale, sold with, or installed on a new motor vehicle prior to or concurrent with transfer to an ulimate purchaser

2. This Executive Orderis valid provided that the installation instructions for the Fast Forward Supercharger Kit will not recommend tuning the vehicle to specifications different from those of the vehicle manufacturer. Changes made to the design or operating conditions of the device, as exempted by the Air Resources Board, that adversely affect the performance of a vehicle‘s pollution control system shallinvalidate this Executive Order. Marketing of this device using any identication other than that shown in this Executive Order or marketing ofthis device for an application other than those listed in this Executive Order shall be prohibited unless prior approval is obtained from the Air Resources Board This Executive Order does not constitute any opinion as to the effect that the use of this device may have on any warranty either expressed or implied by the vehicle manufacturer. This exemption is issued based on previously submitted emissions test data from an independentlaboratory on a 2005 mode! year Mazda MX—5 Miata vehicle (Test Group STKXVO1.8NA1) certified to the Low Emission Vehicle (LEV) emission standards, and equiped with the Fast Forward Supercharger Kit (part number FFS01—05—CS) installed. Theexhaust emission measurements from the test vehicle are as follows: Federal Test Procedure: NMos. co NOX HcHO Standards (g/mi) c.o75 4 o2 0015 Device (gimi) with ds applied c.083 13 o.1 0.0005 The test results show that the Fast Forward Supercharger Kit when installed on a representative vehicle wll not likely cause exhaust emissions to exceedthe applicable emission standards during the Cold—Start Federal Test Procedure. This Executive Order is also based on specific On—Board Diagnostic 11 (OBD 11 testing conducted on the modified test vehicle. The Fast Forward Supercharger Kit when installed on the test vehicle did not affect the vehicle‘s abilty to perform its OBD II monitoring in addition, the Air Resources Board reserves the right in the future to review this Executive Order and the exemption provided herein to assure that the exempted add—on or modified part continues to meet the standards and procedures of Title 13, California Code of Regulations, Section 2222, et seq. THIS EXECUTIVE ORDER DOES NOT CONSTITUTE A CERTIFICATION, ACCREDITATION, APPROVAL, OR ANY OTHER TYPE OF ENDORSEMENT BY THE AIR RESOURCES BOARD OF ANY CLAIMS OF THE APPLICANT CONCERNING ANTEPOLLUTION BENEFITS OR ANY ALLEGED BENEFITS OF THE FAST FORWARD SUPERCHARGER KT

53. No claims of any kind, such as *Approved by the Air Resources Board" may be made with respect to the action taken herein in any advertising or other oral or written communication Violation of any of the above conditions shall be grounds for revocation of this order. The order may be revoked only after a ten day writen notice of intention to revoke the order, in which period the holder of the order may request in writing a hearing to contest the proposed revocation. If a hearing is requested, it shall be held within ten days of receipt of the request and the order may not be revoked until a determination is made afterthe hearing that grounds for revocation exist evesuten anel memerpatremenine 22.Wday of May 2015. o I)! fock. Fg@‘—fim‘nene Hebert, Chief Emissions Compliance, Automotive Regulations and Science Division


Document Created: 2015-06-01 11:09:13
Document Modified: 2015-06-01 11:09:13

Previous E.O. D-617-1 | Previous E.O. D-616 | Next E.O. D-617-3 | Next E.O. D-618