Approval Details

Valid E.O.

Validity

This Executive Order approved the specified parts on on March 19, 2008.
As of Thursday, December 13th, 2018 this Executive Order has not been overturned or superceeded.

Approved Parts

Part NumberModelsRemarks
See PDF2008 model year and older on road motorcycles originally equipped with an oxygen sensor, as listed in Exhibit A of Executive Order. See PDFThe Fi2000R-ARB is an electronic control box designed to increase fuel into the combustion chamber during high load conditions. It uses the existing oxygen sensor(s) to monitor air/fuel mixtures and increases fuel injector pulse when the oxygen sensor readings show lean conditions. The Fi2000R-ARB is installed electrically in series to the oxygen sensor and the fuel injector wiring harness. No wires are cut during installation and factory style connectors are pre-installed on the wiring harness of the Fi2000R-ARB. The Fi2000R-ARB has no user adjustments and is not designed to allow a user to download or modify the programming.

This Executive Order may be listed as:
  • C.A.R.B.E.O. D-633
  • Executive Order 633 / D633
  • ARB # D-633
  • Executive Order No: D-633
  • C.A.R.B. No. D-633
  • Resolution D-633
For Free CARB Executive Order Status verification, email an image of the device Executive Order label as well as the Year/Make/Model and Test Group # of the vehicle to [email protected]

Download: Executive Order D-633 PDF

D-633 Document:



                                     State of California
                                 AIR RESOURCES BOARD

                                 EXECU1-IVE ORDER D-633

                        Relating to Exerr~ptionsUnder Section 271 56
                                   of the Califorr~iaVehicle Code

                                      Cobra Engineering
                                        Fi2000R-ARB

Pursuant to the authority vested in the Air Reso~~rces
                                                    Board by Section 27156 of the
Vehicle Code; and

Pursuant to the authority vested in the undersigned by Section 39515 and
Section 39516 of the Health and Safety Code and Executive Order G-02-003;

IT IS ORDERED AND RESOLVED: That the installation of the Fi2000R-ARB, produce? 3
and marketed by Cobra Engineering of 23801 E. La Palma Avenue, Yorba Linda,
California 92887, has been found not to reduce the effectiveness of the applicable vetI C
pollution control systems and, ,therefore, is exempt from the prohibitions of Section 27 15
of the Vehicle Code for the 2008 model year and older on road motorcycles originally
equipped with an oxygen sensor, as listed in Exhibit A.

The Fi2000R-ARB is an electronic control box designed to increase fuel into the
combustion chamber during high load conditions. The Fi2000R-ARB has no user
adjustments and is not designed to allow a user to download or modify the programmi r g

This Executive Order is valid provided the installation instructions for the Fi2000R-ARI3
will not recommend tunirrg the motorcycle to specifications different from those of the
Cobra Engineering.

Changes made to the design or operating conditions of the Fi2000R-ARB, as exempt t Y
the Air Resources Board, which adversely affect the performance of the vehicle's poll1ti(
control system shall invalidate this Executive Order.

Marketing of the Fi2000R-ARB using any identification other than that shown in this
Executive Order .or marketing of the Fi2000R-ARB for an application other than those
listed in this Executive Order shall be prohibited unless prior approval is obtained frorrI tt
Air Resources Board.

This Executive Order does not constitute any opinion as to the effect the use of the
Fi2000R-ARB may have on any warranty either expressed or implied by the vehicle
manufacturer.

This Executive Order is granted based on submitted emission test data generated on t\N
motorcycles using the Cold-Start CVS-75 Federal Test Procedure. Results from emissic
testing conducted at Ecologic Testing Laboratory, located in Fullerton, California, are
shown on page 2. in grams per kilometer.


2007 Yamaha
VStar 1.3L                                        Davidson
                 HC        CO       NOx                            CO
Stock            0.115     1.1 12   0.027        Stock      0.981 -
                                                                  3.692
                                                 -                  - 0.
Device                                           Device     10813.857 0.
                                                 Difference 0.1   0.165 0.
                 -2%                             % Change    10%    4%
Exhaust emissions during comparative Cold-Start CVS-75 Federal Test Procedure
showed that the Fi2000R-ARB did not cause emissions to exceed baseline by more th in
the allowed limits of 10 percent on hydrocarbon (HC) and oxides of nitrogen (NOx), an 1
15 percent on carbon monoxide (CO). Similar effect on motorcycle emissions is expec ted
with 'the installation of the Fi2000R-ARB on motorcycles listed in Exhibit A of this
Executive Order.

The Air Resources Board reserves the right in the future to review this Executive Orde
and the exemption provided herein to assure that the exempted add-on or modified pa t
continues to meet the standards and procedures of Title 13, California Code of
Regulations, Section 2222, et seq.

THIS EXECUTIVE ORDER DOES NOT CONSTITUTE A CERTIFICATION,
                                                                  -
ACCREDITATION, APPROVAL, OR ANY OTHER TYPE OF ENDORSEMENT BY Tl- --
AIR RESOURCES BOARD OF ANY CLAIMS OF THE APPLICANT CONCERNING
ANTI-POLLUTION BENEFITS OR ANY ALLEGED BENEFITS OF COBRA
ENGINEER1NG'S F12000R-ARB.

No claim of any kind, such as "Approved by the Air Resources Board", may be made L ith
respect to the action taken herein in any advertising or other oral or written
communication.

Violation of any of the above conditions shall be grounds for revocation of this order. . he
order may be revoked only after a ten-day written notice of intention to revoke the ordt r,
in which period the holder of the order may request in writing a hearing to contest the
proposed revocation. If a hearing is requested, it shall be held within ten days of recei ,t
of the request and the order may not be revoked until a determination is made after th
hearing that grounds for revocation exist.

Executed at El Monte, California, this      I7      day of March 2008.



                                Annette Hebert, Chief
                                Mobile Source Operations Division




                     COBRA ENGINEERING - F12000-ARB - D-633


                                             Exhibit A
             BRAND   '               PART #                           MODEL FITMENT

                CLOSED LOOP (Motorcycles equipped with an 0 2 sensor)
    Harley              692-1608CL-50         Dresser 2007 (ARB)
                        692-1612CL-50         Dresser 2008 (ARB)
                        692-1609CL-50         Dyna 2006 (ARB)
                        692-1606CL-50         Dyna 07-08 (ARB)
                        692-161 1CL-50                   I
                                              Rocker 2008 (ARB)


                         1 692-1613CL-50                 I V-Rod 2008 (ARB)
                         I                               I
    Honda                    92-1650CL-50                    VTX1800C/R/S/F/N 02-08 (ARB)

    Kawasaki                 92-19 6 4 ~ ~ - 5 0             Vulcan 2000 04-08 (ARB)
                                         1
                                                             Vulcan 2000 Classic 06-08 (ARB)
                                        I,
                                                             Vulcan 2000 Classic LT 06-08 (ARB)

(   Yarnaha              I 92-1771CL-50                  I Road Star 2008 (ARB)
                         1 92-1773CL-50                  I Roadlinerlstratoliner 06-08 (ARB)
                         1 92-1774CL-50                  I V-Star 1300TTourer 07-08 (ARB)
1                        1 92-1777CL-50                  ( Raider 2008 (ARB)

    Victory                  92-1051CL-50                    Vegas 2008
                             92-1051CL-50                    Kingpin 2008
                             92-1051CL-50                    Hammer 2008
                             92-1051CL-50                    Jackpot 2008


         CLOSED LOOP SPORTBIKE (Motorcycles equipped with an 0 2 sensor)
    Honda             92-5002CL-50         CBR600F4i 01-07
                      92-5005CL-50         CB919 02-08

    Kawasaki                 92-5056CL-50                     Z X l OR 08
                             92-5055CL-50                     Z1000 07-08

I Suzuki                 1 92-511OCL-50                      I GSXR1000 07-08                     1
    Yarnaha                  92-5157CL-50                     YZF-R6 06-07
                             92-5161CL-50                     YZF-R1 07-08
                             92-5156CL-50                     FZ6 04-07



Document Created: 2008-04-02 16:41:48
Document Modified: 2008-04-02 16:41:48

| Previous E.O. D-632 | Next E.O. D-633-1 | Next E.O. D-634