Approval Details

Valid E.O.

Validity

This Executive Order approved the specified parts on on June 29, 2016.
As of Monday, November 25th, 2024 this Executive Order has not been overturned or superceeded.

Approved Parts

Part Number
See PDF

This Executive Order may be listed as:
  • C.A.R.B.E.O. D-695-1
  • Executive Order 695-1 / D695-1
  • ARB # D-695-1
  • Executive Order No: D-695-1
  • C.A.R.B. No. D-695-1
  • Resolution D-695-1
For Free CARB Executive Order Status verification, email an image of the device Executive Order label as well as the Year/Make/Model and Test Group # of the vehicle to [email protected]

Download: Executive Order D-695-1 PDF

D-695-1 Document:

CARB_D-695-1

State of California AIR RESOURCES BOARD EXECUTIVE ORDER D—695—1 Relating to Exemptions Under Section 27156 of the California Vehicle Code Sprintex Ltd. Supercharger Kit Pursuant to the authority vested in the Air Resources Board by Section 27156 of the Vehicle Code; and Pursuant to the authority vested in the undersigned by Section 39515 and Section 39516 of the Health and Safety Code and Executive Order G—14—012; IT IS ORDERED AND RESOLVED: That the installation of the Supercharger Kit, manufactured and marketed by Sprintex Ltd., 183 Mulgul Road, Malaga, Western Australia 6090, has been found not to reduce the effectiveness of the applicable vehicle pollution control systems and, therefore, is exempt from the prohibitions of Section 27156 of the Vehicle Code for the following Chrysler vehicles equipped with a 3.6, 3.8 or 4.0 liter gasoline engine: PtNumber Description Vehicle Year Engine 2BiAIDDs leupercharget EL Jeep Wrangler (JK) 2007—11|3.8L 264A1007 |Supercharger Kit w/ Intercooler 263A1001 |Supercharger Kit w/ Intercooler Jeep Wrangler (JK) 2012—16 |3.6L 257A1001 |Supercharger Kit Jeep Wrangler (TJ) 2005—06 }4.0L 3. 2711001 |Supercharger Kit w/ Intercooler Ram 1500 (auto only) 2013—16 § g:: 2011—15|3. 273A1001 Supercharger Kit w/ Intercooler feap Rrand Charokes {suto.only] 20 29. Dodge Durango 2011—15|3.6L Dodge Challenger 2011—16 |3.6L 3.6L Dodge Ch uto onl 2011—16 272A1001 Supercharger Kit w/ Intercooler adge thaiger (s v) 3.6L Chrysler 300C, 3005 (auto only) |2011—16 22t The Supercharger Kit consists of following main components: Sprintex $5—335 screw type compressor with a 69 mm diameter pulley, intake manifold, bypass valve, intercooler, fuel injectors, MAP sensor, and a reflashed ECM (no user adjustments). Boost is limited to 9.0 pounds per square inch. The stock air cleaner housing, crankshaft pulley, and thermostat are retained. All supplied fuel hoses are Avon‘s CADbar 9000 series or a stock replacement, and fuel and vapor line connectors supplied with the kit are OEM — equivalent parts. Breather hoses may be replaced with an SAE30RY rated hose or a stock replacement. Premium only label included for inside of fuel door.

This Executive Order is valid provided that the installation instructions for the Supercharger Kit will not recommend tuning the vehicle to specifications different from those of Sprintex Ltd. Changes made to the design or operating conditions of the Supercharger Kit, as exempt by the Air Resources Board, which adversely affect the performance of the vehicle‘s pollution control system shall invalidate this Executive Order. This exemption is issued based on submitted emissions test data, from the SEMA Garage, Diamond Bar, California, on a 2015 model year Jeep Wrangler, certified to the LEV II ULEV emission standards and tested using the Cold—Start CVS—75 Federal Test Procedure (FTP) test cycle and the Supplemental Federal Test Procedure (SFTP USO6/SC03 (AC2 test + 20%)) test cycle. CVS—75 FTP NMOG CO NOx HCHO Standards, UL 0.070 2.1 0.040 0.011 Device Test 0.046 1.2 0.036 0.002 (w/ df applied, 2 test avg) USO6/SCO3 NMHC+NOx CO Standards 4k 0.14/0.20 8.0/2.7 Device 0.12/0.04 6.3/2.0 Test results showed that the Supercharger Kit when installed on the vehicle did not cause exhaust emissions to exceed the applicable emission standards during the FTP and SFTP. This Executive Order is also based on the On—Board Diagnostic II (OBD II) testing conducted on the same test vehicle. The Supercharger Kit when installed on the test vehicle did not affect the vehicle‘s ability to perform its OBD II monitoring. The Air Resources Board reserves the right in the future to review this Executive Order and the exemption provided herein to assure that the exempted add—on or modified part continues to meet the standards and procedures of Title 13, California Code of Regulations, Section 2222, et seq. THIS EXECUTIVE ORDER DOES NOT CONSTITUTE A CERTIFICATION, ACCREDITATION, APPROVAL, OR ANY OTHER TYPE OF ENDORSEMENT BY THE AIR RESOURCES BOARD OF ANY CLAIMS OF THE APPLICANT CONCERNING ANTI—POLLUTION BENEFITS OR ANY ALLEGED BENEFITS OF THE SUPERCHARGER KIT. SPRINTEX LTD. — SUPERCHARGER KIT — D—695—1

No claim of any kind, such as "Approved by the Air Resources Board", may be made with respect to the action taken herein in any advertising or other oral or written communication. Violation of any of the above conditions shall be grounds for revocation of this order. The order may be revoked only after a ten—day written notice of intention to revoke the order, in which period the holder of the order may request in writing a hearing to contest the proposed revocation. If a hearing is requested, it shall be held within ten days of receipt of the request and the order may not be revoked until a determination is made after the hearing that grounds for revocation exist. Executed at El Monte, California, this !__"_ 297‘( day of June 2016. 7% Annette Hebert, Chief m|ssuons Compliance, Automotive Regulations and Science Division SPRINTEX LTD. — SUPERCHARGER KIT — D—695—1



Document Created: 2016-08-01 16:57:37
Document Modified: 2016-08-01 16:57:37

Previous E.O. D-695 | Previous E.O. D-694 | Next E.O. D-695-2 | Next E.O. D-696