Approval Details

Valid E.O.

Validity

This Executive Order approved the specified parts on on July 14, 2014.
As of Friday, December 14th, 2018 this Executive Order has not been overturned or superceeded.

Approved Parts

Part Number
see pdf

This Executive Order may be listed as:
  • C.A.R.B.E.O. D-236-17
  • Executive Order 236-17 / D236-17
  • ARB # D-236-17
  • Executive Order No: D-236-17
  • C.A.R.B. No. D-236-17
  • Resolution D-236-17
For Free CARB Executive Order Status verification, email an image of the device Executive Order label as well as the Year/Make/Model and Test Group # of the vehicle to [email protected]

Download: Executive Order D-236-17 PDF

D-236-17 Document:



                                   State of California
                               AIR RESOURCES BOARD

                             EXECUTIVE ORDER D—236—17

                      Relating to Exemptions Under Section 27156
                                 of the California Vehicle Code

                      Automotive Performance Systems, Inc.
              Neuspeed Front Mount Intercooler Kit and Intercooler Pipes

Pursuant to the authority vested in the Air Resources Board by Section 27156 of the
Vehicle Code; and

Pursuant to the authority vested in the undersigned by Section 39515 and Section 39516
of the Health and Safety Code and Executive Order G—14—012;

IT IS ORDERED AND RESOLVED: That the installation of the Neuspeed Front Mount
Intercooler Kit and Intercooler Pipes , manufactured and marketed by Automotive
Performance Systems, Inc., 3300 Corte Malpaso, Camarillo, CA 93012, has been found
not to reduce the effectiveness of the applicable vehicle pollution control systems and,
therefore, is exempt from the prohibitions of Section 27156 of the Vehicle Code for 2000
to 2015 model year Volkswagen and Audi vehicles, as listed in Exhibit A.

The Neuspeed Front Mount Intercooler Kit consists of a new intercooler with intake
tubing (pre and post intercooler). No other changes or modifications are made for
installation. The Neuspeed Hi—Flo Turbo Discharge Pipe and Hi—Flo Air Charge Pipe,
can be installed together or separate, for use with the stock intercooler.

This Executive Order is valid provided that the installation instructions for the Neuspeed
Front Mount Intercooler Kit and Intercooler Pipes will not recommend tuning the vehicle
to specifications different from those of the kit manufacturer.

Changes made to the design or operating conditions of the Neuspeed Front Mount
Intercooler Kit and Intercooler Pipes, as exempt by the Air Resources Board, which
adversely affect the performance of the vehicle‘s pollution control system shall invalidate
this Executive Order.

This Executive Order is granted based on submitted emission test data generated on one
test vehicle modified with the Neuspeed Front Mount Intercooler Kit. Test results showed
that emission levels, with the Neuspeed Front Mount Intercooler Kit installed, met the
applicable emission standards when tested using the Cold—Start Federal Test Procedure
test cycle and the Supplemental Federal Test Procedure (SFTP) test cycle. Examination of
the.OBD II system showed that the intercooler kit did not affect OBD II system operation.


    This exemption is issued based on submitted emissions test data, from Automotive Testing
    and Development Services, Inc. of Ontario, California, on a 2014 model year VW Jetta
    (Test Group EVWXVO2.03PA) certified to the Low Emission Vehicle II Super Ultra Low
    Emission Vehicle (LEV II SULEV) standards and tested using the Cold Start Federal Test
    Procedure and the Supplemental Federal Test Procedure (SFTP USO6) test cycle:

                                              CVS—75 FTP
                                      NMOG       CO    NOx             HCHO
    Standards, Useful Life            0.010      1.0   0.02            0.004
    Device Test w/df                  0.004      0.1   0.01            0.000

                                                 USO6
                                   NMHC+NOx              co
    Standards 4k                      0.14               8.0
    Device                            0.08               9.5

    The Air Resources Board reserves the right in the future to review this Executive Order and
    the exemption provided herein to assure that the exempted add—on or modified part
    continues to meet the standards and procedures of Title 13, California Code of
    Regulations, Section 2222, et seq.

    THIS EXECUTIVE ORDER DOES NOT CONSTITUTE A CERTIFICATION,
    ACCREDITATION, APPROVAL, OR ANY OTHER TYPE OF ENDORSEMENT BY THE
    AIR RESOURCES BOARD OF ANY CLAIMS OF THE APPLICANT CONCERNING
    ANTI—POLLUTION BENEFITS OR ANY ALLEGED BENEFITS OF THE NEUSPEED
    FRONT MOUNT INTERCOOLER KIT AND INTERCOOLER PIPES.

    This Executive Order shall not apply to any Neuspeed Front Mount Intercooler Kit and
    Intercooler Pipes advertised, offered for sale, sold with, or installed on a new motor vehicle
    prior to or concurrent with transfer to an ultimate purchaser.

    Marketing of the Neuspeed Front Mount Intercooler Kit and Intercooler Pipes using any
    identification other than that shown in this Executive Order or marketing of the Neuspeed
    Front Mount Intercooler Kit and Intercooler Pipes for an application other than those listed
    in this Executive Order shall be prohibited unless prior approval is obtained from the Air
    Resources Board.

    No claim of any kind, such as "Approved by the Air Resources Board", may be made with
    respect to the action taken herein in any advertising or other oral or written communication.

    Violation of any of the above conditions shall be grounds for revocation of this order. The
    order may be revoked only after a ten—day written notice of intention to revoke the order, in
    which period the holder of the order may request in writing a hearing to contest the
    proposed revocation. If a hearing is requested, it shall be held within ten days of receipt of
    the request and the order may not be revoked until a determination is made after the
    hearing that grounds for revocation exist.

    Executed at El Monte, California, this      /2 A day of July 2014.




              PEX te Hebert, Chief
             Efifissmns Compliance, Automotive Regulations and Science Division


AUTOMOTIVE PERFORMANCE SYSTEMS, INC.—NEUSPEED FRONT MOUNT INTERCOOLER KIT AND
                            INTERCOOLER PIPES—D—236—17


                                                                               I
                                                                            Exhibit A

                                                     NEUSPEED_ FRONT MOUNT INTERCOOLER KIT
                                                      NEUSPEED HI—FLO TURBO DISCHARGE PIPE
                                                         NEUSPEED HI—FLO AIR CHARGE PIPE

MAKE / MODEL       __                     [vear            |EnGine             PART NUMBER
                                         _L__
AUDIA3                                    |2006—2013           2.0L TUREO       1IC KIT: 48.02.92,
                                                                               |Discharge: 48.02.65, 48.02.67, 48.02.69, 48.02.70, 48.02.71, 48.02.95
                                                                               [Air Charge: 48.02.66, 48.02.68

AUDI TT COUPE & ROADSTER                      2008—2014        2.0L TUREO      IC KIT: 48.02.91
                                          |                                    Discharge: 48.02.65, 48.02.67, 48.02.69, 48.02.70, 48.02.71, 48.02.74
                                                                               Air Charge: 48.02.66, 48.02.68

AUDI TTS COUPE & ROADSTER                     2009—2014    |2.0L TUREO         |IC KIT: 48.02.91
                                                                               |Discharge: 48.02.69

VW GOLF IV, GTi, 337, 20TH ANNIVERSARY        2000—2005        1.8L TUREO       IC KIT: 48.10.90, 48.10.91
                                                                                IC Pipe: 48.10.85

VW JETTA IV, GL, SEDAN & WAGON                2000—2005        1.81 TUREO       IC KIT: 48.10.90, 48.10.91
                                                                                IC Pipe: 48.10. 85

VW GOLF V, GTi                           —(2006—2009           2.0L TUREO       IC KIT: 48.10.93
                                                                               |Discharge: 48.02.65, 48.02.67, 48.02.69, 48.02.70, 48.02.71, 48.02.95
                                                                                Air Charge: 48.02.66, 48.02.68

VW JETTA V, GL, SEDAN & WAGON                 2006—2010    |2.0L TURBO          IC KIT: 48.10.93
                                                                                Discharge: 48.02.65, 48.02.67, 48.02.69, 48.02.70, 48.02.71, 48.02.95
                                                                               |Air Charge: 48.02.66, 48.02.68


vw EOS                                        |2008—2014       2.0L TUREO       IC KIT: 48.10.93
                                                                                Discharge: 48.02.65, 48.02.67, 48.02.69, 48.02.70, 48.02.71, 48.02.96
                                                                               |Air Charge: 48.02.66, 48.02.68

VW PASSAT SEDAN & WAGON                       2006—2011        2.0L TUREO      1IC KIT: 48.10.93
                                                                                Discharge: 48.02.65, 48.02.67, 48.02.69, 48.02.70, 48.02.71, 48.02.96
                                                                                Air Charge: 48.02.66, 48.02.68

vW GOLF VI, GTi                               2010—2015    |2.0. TUREO         |iC KiT: 48.10.95
                                                                                Discharge: 48.02.71, 48.02.96
                                                                                Air Charge: 48.02.68

VW GOLF R                                     2012—2013    12.0L TURBO          IC KIT: 48.10.95
                                                           |                    Discharge: 48.02.69
                                                           |                    Air Charge: 48.02.64
                                                           |
vw c                                          2009—2015        2.0L TURBO       IC KIT: 48.02.94
                                                                               |Discharge: 48.02.69, 48.02.71
                                                                               |Air Charge: 48.02.68

VWJETTA VI, GLI SEDAN & WAGON_                (2011—2015       2.0L TUREO       1C: 48.02.49
                                                                                Discharge: 48.02.71
                                                                                Air Charge: 48.02.72

VW JETTA VI SEDAN & WAGON                                      1.8 TURBO        IC KIT: 48.02.49
                                                                               | Discharge: 48.02.71
                                                                               |Air Charge: 48.02.72

VW PASSAT                                                      1.8L TURBO      |iC KiT: 48.02.94
                                                                                Discharge: 48.02.71
                                                                                Air Charge: 48.02.72





Document Created: 2014-09-16 11:08:01
Document Modified: 2014-09-16 11:08:01

Previous E.O. D-236-16 | Previous E.O. D-235 | Next E.O. D-236-18 | Next E.O. D-237