Approval Details

Valid E.O.

Validity

This Executive Order approved the specified parts on on January 16, 2006.
As of Saturday, December 21st, 2024 this Executive Order has not been overturned or superceeded.

Approved Parts

Models
NOT LEGAL FOR SALE OR INSTALLATION AFTER 12/31/08

This Executive Order may be listed as:
  • C.A.R.B.E.O. D-562-1
  • Executive Order 562-1 / D562-1
  • ARB # D-562-1
  • Executive Order No: D-562-1
  • C.A.R.B. No. D-562-1
  • Resolution D-562-1
For Free CARB Executive Order Status verification, email an image of the device Executive Order label as well as the Year/Make/Model and Test Group # of the vehicle to [email protected]

Download: Executive Order D-562-1 PDF

D-562-1 Document:

CARB_D-562-1

State of California AIR RESOURCES BOARD EXECUTIVE ORDER D—562—1 Relating to Exemptions under Section 27156 of the Vehicle Code Valina, Inc. (d.b.a. Car Tex) "Series 12500 OBD If Compliant Three—way Catalytic Converter" WHEREAS, Vehicle Code Sections 27156 and Section 2222(h), Title 13, California Code of Regulations (hereafter "CCR"), authorize the California Air Resources Board and its Executive Officer to exempt new aftermarket catalytic converters from the prohibitions of Vehicle Code Section 27156. WHEREAS, Valina, Inc. (Valina) of 2035 East Vernon Avenue, Vernon, California 90058, has applied to the Air Resources Board for exemption from the prohibitions in Vehicle Code Section 27156 to market its new aftermarket Series 12500 three—way catalytic converter (TWC) for installation on selected 1998 through 2001 model year Toyota passenger cars and light—duty trucks 1 equipped with on—board diagnostic II (OBD—II) systems as specified in Appendix D—562—1 and incorporated herein. The Series 12500 TWC will be used for single (one unit) exhaust system applications. ‘ The TWC may also be installed on non—OBD 11 vehicles (1995 and older) similar in engine and exhaust configuration to those listed in Appendix D—562—1. WHEREAS, pursuant to the authority vested in the Executive Officer by Health and Safety Code Section 39515 and in the Chief, Mobile Source Operations Division by Health and Safety Code Section 39516 and Executive Order G—02—003, the Air Resources Board finds that the above aftermarket catalytic converter complies with the California Vehicle Code Section 27156 and Title 13, California Code of Regulations, Section 2222(h). The emissions performance of the catalytic converter was based on durability bench—aging by Umicore Automotive Catalyst Corporation using Air Resources Board—modified RAT—A bench—aging cycle for 75 hours, as specified in the "Optional Evaluation Procedures for New Aftermarket Non—original Equipment Catalytic Converters Equipped with On—Board Diagnostic II (OBD I1) Systems." WHEREAS, emissions tests conducted at Siemens ADO Automotive Test Center (Siemens), Auburn Hills, Michigan, using a 2001 1.8L Toyota Corolla equipped with a single exhaust system, and certified to the Low Emission Vehicle (LEV, PC) emission standards showed that the vehicle met the applicable emission standards with Series 12500 TWC (one unit) installed. OBD 11 compatibility tests performed on the same test vehicle showed that Series 12500 TWC did not affect the vehicle‘s ability to perform OBD II system monitoring. Emission test results in grams per mile are shown below.

Siemens, Auburn Hills, Michigan 1.8L Toyota Corolla Test NMOG CO NOx Remarks 100K Standard 0.090 4.2 0.3 Test 1 0.081 0.8 0.3 Pass Test 2 0.085 0.7 0.3 Pass IT IS HEREBY RESOLVED that the above catalytic converter is exempt from the prohibitions in Vehicle Code Section 27156 for installation on the approved vehicle applications specified in Appendix D—562—1 subject to the following conditions: 1. No changes are permitted to the catalytic converter as described in the application for exemption. Any changes to the catalytic converter or any of its components, and other factors addressed in this order must be evaluated and approved by the Air Resources Board prior to marketing in California. Marketing of the catalytic converter using identifications other than those shown in the exemption application, and in this Executive Order, or marketing of the catalytic converter for application other than the ones shown in this Executive Order shall be prohibited unless prior approval is obtained from the Air Resources Board. Exemption of these products shall not be construed as an exemption to sell, offer for sale, or advertise any components of the catalytic converter as individual devices. Any oral or written references to this Executive Order or its content by Valina, Inc., its principals, agents, employees, distributors, dealers, or other representatives must include the disclaimer that the Executive Order or the exemption it provides is not an endorsement or approval of any emission reduction claims for the catalytic converter and is only a finding that the catalytic converter is exempt from the prohibitions of Vehicle Code Section 27156. Valina, Inc.‘s installation instructions for the new catalytic converter must conform to requirements in Paragraphs | and X of the "Optional Evaluation Procedures for New Aftermarket Non—original Equipment Catalytic Converters Equipped with On—Board Diagnostic II (OBD {!) Systems." Upon instaliation, the catalytic converter must carry a manufacturer‘s warranty for 50,000 miles on the substrates and 50,000 miles or five years on the shell and end pipes. Valina, Inc. and its vendors may not advertise the new aftermarket catalytic converter as a "high or easy flow" catalytic converter or use any phrase that could make it appear to perform better than an OEM catalytic converter. VALINA, INC. — CATALYTIC CONVERTER — D—562—1

—3 — 7. Valina, Inc., its associates, vendors, other businesses, and individuals may not sell or supply the substrates of the new aftermarket catalytic converter to a third party to be assembled in a different facility and marketed under this Executive Order. 8. Any marketing arrangement of the new aftermarket catalytic converter by a third party, which involves the use of packaging identification different from the ones described in this Executive Order, must be approved by ARB prior to shipment. Violation of any of the above conditions shall be grounds for revocation of this order. The order may be revoked only after a ten day written notice of intention to revoke it, during which period the holder of the order may request in writing a hearing to contest the proposed revocation. If a hearing is requested, it shall be held within ten days of receipt of the request, and the order may not be revoked until a determination is made, after the hearing, that grounds for revocation exist. {4 Executed at El Monte, California, this Z 2 /c;ay of January 2006. Lyons n Chief Mobile Source Operations Division VALINA, INC. — CATALYTIC CONVERTER — D—562—1

APPENDIX D—5 @1 VALINA INC. — TOYOTA 12500 SERIES OBD II CONVERTER APPLICATION Model Vehicle Model No. of Engine Family Certification Total Monitored Unmonitored Universal Direct Fit Year Cylinders Level Converters _L_ 1998 Corolla 4 WITYXVOT.8DXB TLEV 1 1 NONE 12502 N/A 1998 Tercel, Paseo, Paseo Convertible 4 WTYXVO1.5BBA T1 1 1 NONE 12502 N/A 1999 Tercel 4 XTYXVO1.5BBA 1 1 NONE 12502 N/A 1999 Paseo, Paseo Convertible 4 1 1 NONE 12502 N/A 1999 Camry 6 XTYXVO3.0BBA 1 1 NONE 12502 N/A 1999 Camry Solara 6 1 1 NONE 12502 N/A 1999 Corolia 4 XTYXVO1.8DXB TLEV 1 1 NONE 12502 N/A 1999 Tacoma 2WD 6 XTYXTO3.4BBH T1 1 1 NONE 12503 N/A 1999 Tacoma 2WD, 4WD 4 XTYXTO2.7BBH 1 1 NONE 12503 N/A 2000 Echo 4 YTYXVO1.5FFA LEV 1 1 NONE 12501 N/A 2000 Camry Solara 6 YTYXVO3.0BBA T1 1 1 NONE 12502 N/A 2000 Celica 4 YTXVO1.8DDB8B TLEV 1 1 NONE 12502 N/A 2000 Corolla 4 YTYXVO1.8FFA LEV 1 1 NONE 12501 N/A 2001 Echo 4 1TYXVO1.5FFA 1 1 NONE 12502 N/A 2001 Celica 4 1TYXVO1.8DDB TLEV 1 1 NONE 12502 N/A 2001 Corolla 4 1TYXVO1.8FFA LEV 1 1 NONE 12502 N/A 2001 Celica 4 1TYXVO1.8DDC TLEV 1 1 NONE 12502 N/A Page 1 of 1


Document Created: 2006-09-06 11:32:21
Document Modified: 2006-09-06 11:32:21

Previous E.O. D-562 | Previous E.O. D-561 | Next E.O. D-562-2 | Next E.O. D-563