Approval Details

Valid E.O.


This Executive Order approved the specified parts on on January 31, 2005.
As of Friday, September 20th, 2019 this Executive Order has not been overturned or superceeded.

Approved Parts

Part NumberModels
1006DODGE1999-2002 Chrysler Dodge Ram 1500 5.2, 5.9 L

This Executive Order may be listed as:
  • C.A.R.B.E.O. D-586
  • Executive Order 586 / D586
  • ARB # D-586
  • Executive Order No: D-586
  • C.A.R.B. No. D-586
  • Resolution D-586
For Free CARB Executive Order Status verification, email an image of the device Executive Order label as well as the Year/Make/Model and Test Group # of the vehicle to [email protected]

Download: Executive Order D-586 PDF

D-586 Document:

                                     State of California
                                AIR RESOURCES BOARD

                                EXECUTIVE ORDER D—586

                       Relating to Exemptions Under Section 27156
                                  of the California Vehicle Code

                                      Clear Innovation
                                           AirBoZz _

Pursuant to the authority vested in the Air Resources Board by Section 27156 of the
Vehicle Code; and

Pursuant to the authority vested in the undersigned by Section 39515 and Section
39516 of the Health and Safety Code and Executive Order G—02—003;

IT IS ORDERED AND RESOLVED: That the installation of the AirBoz, produced and
marketed by Clear Innovation of 28 Flower Street, Redwood City, California 94063, has
been found not to reduce the effectiveness of the applicable vehicle pollution control
systems and, therefore, is exempt from the prohibitions of Section 27156 of the Vehicle
Code for the vehicles listed in Exhibit A.

The AirBoz consists of a non—motorized plastic propeller that is fastened to a bearing on
a sheet metal assembly for installation on the inlet side of a vehicle throttle body.

This Executive Order is valid provided that the instailation instructions for the AirBoz will
not recommend tuning the vehicle to specifications different from those of the vehicle —

Changes made to the design or operating conditions of the AirBoz, as exempt by the Air
Resources Board, which adversely affect the performance of the vehicle‘s pollution
control system shall invalidate this Executive Order.

This Executive Order shall not apply to any AirBoz advertised, offered for sale, sold
with, or installed on a new motor vehicle prior to or concurrent with transfer to an
ultimate purchaser.

Marketing of the AirBoz using any identification other than that shown in this Executive
Order or marketing of the AirBoz for an application other than those listed in this
Executive Order shall be prohibited unless prior approval is obtained from the Air
Resources Board.

This Executive Order does not constitute any opinion as to the effect the use of the
AirBoz units may have on any warranty either expressed or implied by the vehicle

This Executive Order is granted based on examination of the On—Board Diagnostic II
(OBD !1) system in the modified configuration of a 2004 Ford F—150 with a 5.4 liter


 engine (4FMXTO5.4R4P, LEV—II LEV). Results from examination of the OBD II system
 conducted at the Automobile Club of Southern California showed the AirBoz does not
 affect OBD 1| operation.                        —

 The ARB finds that reasonable grounds exist to believe that use of the AirBoz may
 adversely affect emissions of motor vehicles when operating under conditions outside
 the parameters of the CVS—75 Federal Test Procedure. Accordingly, the ARB reserves
 the right to conduct additional emission tests, in the future, as such tests are developed,
 that will more adequately measure emissions from all cycle phases. If such test results
 demonstrate that the AirBoz adversely affect emissions during off—cycle conditions
 (defined as those conditions which are beyond the parameters of the Colid—Start CVS—75
 Federal Test Procedure), this Executive Order shall be effectively rescinded as of the
 date the test results are validated. Further, if such test results or other evidence
 provides the ARB with reason to suspect that the AirBoz will affect the durability of
 emission control systems, Clear Innovation shall be required to submit durability data to
 show that the durability of vehicle emission control systemsare not, in fact, affected
 and/or that the add—on or modified part demonstrates adequate durability.

 The ARB reserves the right in the future to review this Executive Order and the
 exemption provided herein to assure that the exempted add—on or modified part
 continues to meet the standards and procedures of Title 13, California Code of
 Regulations, Section 2222, et seq.


«No claim of any kind, such as "Approved by the Air Resources Board", may be made
with respect to the action taken herein in any advertisingor other oral or written

  Violation of any of the above conditions shall be grounds for revocation of this order.
  The order may be revoked only after a ten—day written notice of intention to revoke the
  order, in which period the holder of the order may request in writing a hearing to contest
  the proposed revocation. If a hearing is requested, it shall be held within ten days of
  receipt of the request and the order may not be revoked until a determination is made
— after the hearing that grounds for revocation exist.

 Executed at El Monte, California, this   _/ 37      day of January 2005.

                                 Allepfyons, Chief
                                 Mobile Source Operations Division

                            CLEAR INNOVATION — AIRBOZ — D—586

                                     Exhibit A                                  D—586

 Part Number Model—Year   Make               Model             Engine Size
1006DODGE 1999—2002 Chrysler           Dodge Ram 1500            5.2, 5.9 L
  1006JEEP      1998    Chrysler        Jeep Cherokee              4.0 L
  1005FORD      2004      Ford     F—150 (normally aspirated)      5.4 L
  1010FORD      1995      Ford             Mustang                 3.6 L
   1002GM    2003—2004     GM                Truck            4.8, 5.3, 6.0 L
   1003GM    1996—1998     GM                Truck              5.0, 5.7 L
 1007CHEVY      2000       GM                S—10                  2.2 L
 1008CHEVY 1998—2000       GM                S—10                  4.3 L
1009SUBARU      1999    Subaru             Forester                2.5 L

                                   Page 1 of 1

Document Created: 2005-09-01 12:39:56
Document Modified: 2005-09-01 12:39:56

| Previous E.O. D-585 | Next E.O. D-586-1 | Next E.O. D-587