Approval Details

Valid E.O.

Validity

This Executive Order approved the specified parts on on April 21, 2003.
As of Thursday, January 2nd, 2025 this Executive Order has not been overturned or superceeded.

Approved Parts

Part NumberModels
172-0562001 to 2003 Ford Mustang GT

This Executive Order may be listed as:
  • C.A.R.B.E.O. D-473-8
  • Executive Order 473-8 / D473-8
  • ARB # D-473-8
  • Executive Order No: D-473-8
  • C.A.R.B. No. D-473-8
  • Resolution D-473-8
For Free CARB Executive Order Status verification, email an image of the device Executive Order label as well as the Year/Make/Model and Test Group # of the vehicle to [email protected]

Download: Executive Order D-473-8 PDF

D-473-8 Document:

CARB_D-473-8

State of California AIR RESOURCES BOARD EXECUTIVE ORDER D—473—8 Relating to Exemptions Under Section 27156 of the California Vehicle Code Saleen Performance Saleen Enhanced Fuel Calibration Pursuant to the authority vested in the Air Resources Board by Section 27156 of the Vehicle Code; and ' Pursuant to the authority vested in the undersigned by Section 39515 and Section 39516 of the Health and Safety Code and Executive Order G—02—003; IT IS ORDERED AND RESOLVED: That the installation of the Saleen Enhanced Fuel Calibration, produced and marketed by Saleen Performance 76 Fairbanks, Irvine, California 92618, has been found not to reduce the effectiveness of the applicable vehicle pollution control systems and, therefore, is exempt from the prohibitions of Section 27156 of the Vehicle Code for the 2001 to 2003 Ford Mustang GT (p/n 172— 056). The Saleen Enhanced Fuel Calibration consists of a Ford processor that is reprogrammed for more aggressive fuel and spark calibrations for use with premium fuel. This Executive Order is valid provided that the installation instructions for the Saleen Enhanced Fuel Calibration will not recommend tuning the vehicle to specifications different from those of the vehicle manufacturer. Changes made to the design or operating conditions of the Saleen Enhanced Fuel Calibration, as exempt by the Air Resources Board, which adversely affect the performance of the vehicle‘s pollution control system shall invalidate this Executive Order. This Executive Order shall not apply to any Saleen Enhanced Fuel Calibration advertised, offered for sale, sold with, or installed on a new motor vehicle prior to or concurrent with transfer to an ultimate purchaser. Marketing of the Saleen Enhanced Fuel Calibration using any identification other than that shown in this Executive Order or marketing of the Saleen Enhanced Fuel Calibration for an application other than those listed in this Executive Order shall be prohibited unless prior approval is obtained from the Air Resources Board.

This Executive Order does not constitute any opinion as to the effect the use of the Saleen Enhanced Fuel Calibration units may have on any warranty either expressed or implied by the vehicle manufacturer. This Executive Order is granted based on emission results submitted by Saleen Performance in certifying their 2003 Saleen $281 as a small volume new vehicle (E.0. A—324—0012, engine family 3S3XVO4.6JDA) which is certified to the Transitional Low— Emission Vehicle Passenger Car standard (TLEV, PC). The Saleen $281 is a new Ford Mustang that has been modified by Saleen Performance. The certification emission results for the 2003 Saleen $281 are shown below (in grams per mile): 50k NMOG CO NOx HCHO Emission Level 0.111 0.9 0.1 n/a (w. DF applied) STD 0125 3.4 0.4 0.015 100k NMOG CO NOx HCHO Emission Level 0.126 1.0 0.1 n/a (w. DF applied) STD 0.156 4.2 0.6 0.018 The certification emission test results submitted for new vehicle certification have been accepted as representative of emissions in the modified configuration. The certification emission test results were below the applicable certification standards. Examination of the OBD II system was not performed since Saleen Performance has demonstrated OBD II compliance during certification of the Saleen S$281. Therefore, based on the test results, the staff concludes that the Saleen Enhanced Fuel Calibration meets the criteria for exempting general criteria parts. However, the ARB finds that reasonable grounds exist to believe that use of the Saleen Enhanced Fuel Calibration may adversely affect emissions of motor vehicles when operating under conditions outside the parameters of the CVS—75 Federal Test Procedure. Accordingly, the ARB reserves the right to conduct additional emission tests, in the future, as such tests are developed, that will more adequately measure emissions from all cycle phases. If such test results demonstrate that the Saleen Enhanced Fuel Calibration adversely affects emissions during off—cycle conditions (defined as those conditions which are beyond the parameters of the Cold—Start CVS—75 Federal Test Procedure), this Executive Order shall be effectively rescinded as of the date the test results are validated. Further, if such test results or other evidence provides the ARB with reason to suspect that the Saleen Enhanced Fuel Calibration will affect the durability of the emission control system, Saleen Performance shall be required to submit durability data to show that the durability of the vehicle emission control system is not, in fact, affected and/or that the add—on or modified part demonstrates adequate durability. If evidence provides the ARB with reason to suspect that the Saleen Enhanced Fuel Calibration will affect the durability of emission control systems, Saleen Performance shall be required to submit durability data to show that the durability of vehicle emission control systems are not, in fact, affected and/or that the add—on or modified part demonstrates adequate durability. SALEEN PERFORMANCE — SALEEN ENHANCED FUEL CALIBRATION — D—473—8

The ARB reserves the right in the future to review this Executive Order and the exemption provided herein to assure that the exempted add—on or modified part continues to meet the standards and procedures of Title 13, California Code of Regulations, Section 2222, et seq. THIS EXECUTIVE ORDER DOES NOT CONSTITUTE A CERTIFICATION, ACCREDITATION, APPROVAL, OR ANY OTHER TYPE OF ENDORSEMENT BY THE AIR RESOURCES BOARD OF ANY CLAIMS OF THE APPLICANT CONCERNING ANTI—POLLUTION BENEFITS OR ANY ALLEGED BENEFITS OF SALEEN PERFORMANCE‘S SALEEN ENHANCED FUEL CALIBRATION No claim of any kind, such as "Approved by the Air Resources Board", may be made with respect to the action taken herein in any advertising or other oral or written communication. Violation of any of the above conditions shall be grounds for revocation of this order. The order may be revoked only after a ten—day written notice of intention to revoke the order, in which period the holder of the order may request in writing a hearing to contest the proposed revocation. If a hearing is requested, it shall be held within ten days of receipt of the request and the order may not be revoked until a determination is made after the hearing that grounds for revocation exist. Executed at El Monte, California, this _2/7"_ day of April, 2003. ,/./{%/ AllegLyons, Chief Mobile Source Operations Division SALEEN PERFORMANCE — SALEEN ENHANCED FUEL CALIBRATION — D—473—8


Document Created: 2005-09-01 12:40:40
Document Modified: 2005-09-01 12:40:40

Previous E.O. D-473-7 | Previous E.O. D-472 | Next E.O. D-473-9 | Next E.O. D-474