Approval Details

Valid E.O.

Validity

This Executive Order approved the specified parts on on October 23, 2009.
As of Tuesday, December 11th, 2018 this Executive Order has not been overturned or superceeded.

Approved Parts

Part NumberModels
75-15292002-2004 Dodge Ram 1500 4.7L

This Executive Order may be listed as:
  • C.A.R.B.E.O. D-590-2
  • Executive Order 590-2 / D590-2
  • ARB # D-590-2
  • Executive Order No: D-590-2
  • C.A.R.B. No. D-590-2
  • Resolution D-590-2
For Free CARB Executive Order Status verification, email an image of the device Executive Order label as well as the Year/Make/Model and Test Group # of the vehicle to [email protected]

Download: Executive Order D-590-2 PDF

D-590-2 Document:



                                     State of California
                                AIR RESOURCES BOARD

                               EXECUTIVE ORDER D—590—2

                       Relating to Exemptions Under Section 27156
                                  of the California Vehicle Code

                                        S&B Filters
                                  Cold Air Intake System

Pursuant to the authority vested in the Air Resources Board by Section 27156 of the
Vehicle Code; and

Pursuant to the authority vested in the undersigned by Section 39515 and Section
39516 of the Health and Safety Code and Executive Order G—02—003;

T IS ORDERED AND RESOLVED: That the installation of the Cold Air Intake System,
produced and marketed by S&B Filters of 787 S. Wanamaker Ave., Ontario, California
91761, has been found not to reduce the effectiveness of the applicable vehicle
pollution control systems and, therefore, is exempt from the prohibitions of Section
27156 of the Vehicle Code for the vehicles listed in Exhibit A.

The Cold Air Intake System includes the following main components: open—element
reusable air filter, heat shield (as applicable), intake system tubing, crankcase
ventilation hose (as applicable, which may be silicone, and a color other than black),
assorted brackets, and hardware.

This Executive Order is valid provided that the installation instructions for the Cold Air
Intake System will not recommend tuning the vehicle to specifications different from
those of the vehicle manufacturer.

Changes made to the design or operating conditions of the Cold Air Intake System, as
exempt by the Air Resources Board, which adversely affect the performance of the
vehicle‘s pollution control system shall invalidate this Executive Order.

This Executive Order shall not apply to any Cold Air Intake System advertised, offered
for sale, sold with, or installed on a new motor vehicle prior to or concurrent with transfer
to an ultimate purchaser.

Marketing of the Cold Air Intake System using any identification other than that shown in
this Executive Order or marketing of the Cold Air Intake System for an application other
than those listed in this Executive Order shall be prohibited unless prior approval is
obtained from the Air Resources Board.

This Executive Order does not constitute any opinion as to the effect the use of the Cold
Air Intake System units may have on any warranty either expressed or implied by the
vehicle manufacturer.


                                               27—


This Executive Order is granted based on emission test results in the modified
configuration using the Cold—Start Federal Test Procedure, Supplemental Federal Test
Procedure (USO6), and an examination of the On—Board Diagnostic II (OBD II) system.
A 2008 GM Chevrolet Suburban (8GMXTO5.3381, LEV—II ULEV) was used for the
evaluation of the Cold Air Intake System. Results from emissions testing conducted at
the Automotive Testing and Development Services, are shown below (in grams per
mile):                                                                          >

                                2008 GM Chevrolet Suburban

FTP                      120k       NMOG         CO      NOx        HCHO
                 Emission Level 0.034          1.227     0.012     0.0004
                 (w. DF applied)
                         STD        0.070       2.1      0.04      0.011


USO6                     NMHC + NOx          CO
                 Meas.      0.0328           0.959
                 STD        0.4             10.5

The emission test results in the modified configuration were below the applicable
certification standards. Examination of the OBD II system showed the Cold Air Intake
System does not affect OBD 11 operation.

If evidence provides the ARB with reason to suspect that the Cold Air Intake System will
affect the durability of emission control systems, S&B Filters shall be required to submit
durability data to show that the durability of vehicle emission control systems are not, in
fact, affected and/or that the add—on or modified part demonstrates adequate durability.

The ARB reserves the right in the future to review this Executive Order and the
exemption provided herein to assure that the exempted add—on or modified part
continues to meet the standards and procedures of Title 13, California Code of
Regulations, Section 2222, et seq.

THIS EXECUTIVE ORDER DOES NOT CONSTITUTE A CERTIFICATION,
ACCREDITATION, APPROVAL, OR ANY OTHER TYPE OF ENDORSEMENT BY THE
AIR RESOURCES BOARD OF ANY CLAIMS OF THE APPLICANT CONCERNING
ANTI—POLLUTION BENEFITS OR ANY ALLEGED BENEFITS OF S&B FILTERS‘
COLD AIR INTAKE SYSTEM.

No claim of any kind, such as "Approved by the Air Resources Board", may be made
with respect to the action taken herein in any advertising or other oral or written
communication.

Violation of any of the above conditions shall be grounds for revocation of this order.
The order may be revoked only after a ten—day written notice of intention to revoke the
order, in which period the holder of the order may request in writing a hearing to contest
the proposed revocation. If a hearing is requested, it shall be held within ten days of


                     S&B FILTERS — COLD AIR INTAKE SYSTEM — D—590—2


receipt of the request and the order may not be revoked until a determination is made
after the hearing that grounds for revocation exist.

Executed at El Monte, California, this   23        day of October 2009.




                                Annette Hebert, Chief
                                Mobile Source Operations Division




                     S&B FILTERS — COLD AIR INTAKE SYSTEM — D—590—2


                                             Exhibit A                                          D—590—2


   P/N        MFR                                   VEHICLE
 75—1529    Chrysler   |2002—2004 Dodge Ram 1500 4.7L
75—1530—1   Chrysler   |2002—2003 Dodge Ram 5.9L V8
 75—1531    Chrysler   12003—2004 Chrysler PT Cruiser TURBO
 75—1532    Chrysier   |2003—2006 Dodge Ram 2500 & 3500 5.9L Cummins
 75—1533    Chrysler   (2003—2004 Dodge Ram Hemi 5.7L
 75—1534    Chrysler   |2005—2007 Dodge Ram Hemi 5.7L
 75—5025    Chrysier   12007 Jeep Wrangler 3.8L V6
 75—5033    Chrysler   |2003—2007 Dodge Ram 3500/3500 5.91 16

 75—2503     Ford      |1988—1995   Ford   F—150, F—250, F—350, Bronco 4.9L, 5.0L, 5.8L, 7.5L
75—2519—3    Ford      |1996—2004   Ford   Mustang GT 4.6L, excludingt Bullet
 75—2546     Ford      |2003—2006   Ford   Excursion, F—Series Super Duty 6.0L
75—2556—1    Ford      |2005—2006   Ford   F150 Pick—up 5.4L V8
                       2005—2006 Ford Mustang GT 4.6L V8, for 2005 models not equipped
                       with HC adsorber, permitted Ford intake part numbers 6R33—9C662—
                       BG (manual trans) or 6R33—9C662—CG (auto trans), manufactured
 75—5003     Ford      prior to April 2005.
 75—5016     Ford      |2005—2006 Ford F150 Pick—up 5.4L V8
 75—5020     Ford      |2006 Ford F150, 4.6L V8
 75—5022     Ford      |2007 Ford F150 Pick—up, 4.6L V8
 75—5023     Ford      |2004 Ford F150 Pick—up 5.4L V8
                       1999—2006 Chevrolet/GMC Avalance, Silverado, Suburban, Tahoe,
75—3023—1     GM       Denali, Sierra Trucks 4.8L, 5.3L, 6.0L
75—3030—1     GM       |2001—2005 Chevrolet/GMC Trucks 8.11.
 75—3034      GM       __|2001—2004 Chevrolet/GMC Truck LB7 Duramax Diesel
75—3035       GM       2001—2004 Chevrolet Corvette V8, excluding 2003—2004 206
75—5006—1     GM       |2004—2005 Chevrolet/GMC Trucks LLY Duramax Diesel
 75—5011      GM       }2001—2006 WorkHorse Motorhome GM 8.1L
75—5013—1     GM       2006—2007 Chevrolet/GMC Trucks LLY—LBZ Duramax Diesel
 75—5021     GM        2007 Chevrolet/GMC Silverado/Sierra Trucks 4.8L, 5.3L, 6.0L
75—9015—1   Toyota     1999—2003 Toyota Tacoma/ARunner 3.4L V6



Document Created: 2010-03-15 14:19:28
Document Modified: 2010-03-15 14:19:28

Previous E.O. D-590-1 | Previous E.O. D-589 | Next E.O. D-590-3 | Next E.O. D-591