Approval Details

Valid E.O.

Validity

This Executive Order approved the specified parts on on April 13, 2017.
As of Sunday, July 21st, 2019 this Executive Order has not been overturned or superceeded.

Approved Parts

Part Number
See PDF

This Executive Order may be listed as:
  • C.A.R.B.E.O. D-742-1
  • Executive Order 742-1 / D742-1
  • ARB # D-742-1
  • Executive Order No: D-742-1
  • C.A.R.B. No. D-742-1
  • Resolution D-742-1
For Free CARB Executive Order Status verification, email an image of the device Executive Order label as well as the Year/Make/Model and Test Group # of the vehicle to [email protected]

Download: Executive Order D-742-1 PDF

D-742-1 Document:



                                    State of California
                                AIR RESOURCES BOARD

                              EXECUTIVE ORDER D—742—1

                               Relating to Exemptions under
                       Section 27156 of the California Vehicle Code

                                       Hondata, Inc.
                                         FlashPro

Pursuant to the authority vested in the Air Resources Board by Section 27156 of the
Vehicle Code; and

Pursuant to the authority vested in the undersigned by Sections 39515 and 39516 of the
Health and Safety Code and Executive Order G—14—012;

IT IS ORDERED AND RESOLVED: That the installation of the FlashPro, manufactured
and marketed by Hondata, Inc. (Hondata) 2840 Columbia Street, Torrance, California
90503, has been found not to reduce the effectiveness of the applicable vehicle pollution
control systems and, therefore, is exempt from the prohibitions of Section 27156 of the
Vehicle Code for the following vehicle applications:

  Model                     Model Years          Engine

  Honda Civic               2016 to 2017          1.5L

  Honda CRZ                 2010 to 2015          1.5L

  Honda Civic Si            2006 to 2011         2.0L (manual trans only)
                            2012 to 2014         2. AL (manual trans only)

  Honda Civic               2006 to 2014          1.8L

  Honda $2000               2006 to 2009         2.2L (manual trans only)

  Honda Fit                 2007 to 2015          1.BL

  Accord                    2008 to 2015          2 AL

  Accord                    2008 to 2015          3.5L

  Acura TSX                 2004 to 2014          2 AL

  Acura ILX                 2013 to 2015          2 AL

  Acura TL                  2007 to 2008          2 AL

  Acura RDX                 2007 to 2012          2.3L

The FlashPro, is a new electronic control unit calibration, designed to improve the feel
of the vehicle by making modifications to the vehicle‘s rev limiter, throttle response,
speed limiter, camshaft timing, and ignition timing. New calibration is installed using a
laptop, there are no user adjustments to emissions related data files. No other
changes are required for proper installation. Boost on turbo models is increased by
roughly 5 psi.


                                                $.


This Executive Order is valid provided that the installation instructions for the
FlashPro will not recommend tuning the vehicle to specifications different from those
submitted by the vehicle manufacturer.

Changes made to the design or operating conditions of the FlashPro, as exempt by the
Air Resources Board, which adversely affect the performance of the vehicle‘s pollution
control system shall invalidate this Executive Order.

Marketing of the FlashPro using any identification other than that shown in this
Executive Order or marketing of the FlashPro, for an application other than those listed
in this Executive Order shall be prohibited unless prior approval is obtained from the Air
Resources Board.

This Executive Order shall not apply to any FlashPro advertised, offered for sale, sold
with, or installed on a new motor vehicle prior to or concurrent with transfer to an
ultimate purchaser.

This Executive Order does not constitute any opinion as to the effect the use of the
FlashPro may have on any warranty either expressed or implied by the vehicle
manufacturer.

This Executive Order is granted based on submitted emissions test data generated on a
2017 model—year 1.5L Honda Civic (test group HHHXVO1.5562), certified to the Low
Emission Vehicle 3 Super Ultra Low Emission Vehicle 30 (LEV 3 SULEV 30) emission
standards with the FlashPro calibration installed. Testing consisted of a Cold—Start
CVS—75 Federal Test Procedure (FTP) test cycle and the Supplemental Federal Test
Procedure (SFTP USO6/SCO03 (AC2 test + 20%)) test cycle.

Useful Life FTP     NMOG+NOx               Co         HCHO
Emission Level
(w/ df applied,
 2 test avg)           0.020              0.3         0.000

     Standards         0.030              1.0         0.004

Useful Life SFTP           NMOG+NOx             Cco
Emission Level
(Composite w/ df)               0.015           0.3

     Standards                 0.050 (BIN)      4.2

Boost pressure gain was measured at 4.6 psi.

On—Board Diagnostic II (OBD 1I) test data showed that the FlashPro did not affect the
ability to perform OBD II monitoring. The FlashPro should have a similar effect on
emissions and OBD II monitoring for the other vehicles listed in this Executive Order.




                         HONDATA— FLASHPRO — D—742—1


                                            —3—


No claim of any kind, such as "Approved by the Air Resources Board," may be made
with respect to the action taken herein in any advertising or other oral or written
communication.

In addition to the foregoing, the Air Resources Board reserves the right in the future to
review this Executive Order and the exemption provided herein to assure that the
exempted add—on or modified part continues to meet the standards and procedures of
California Code of Regulations, Title 13, Section 2222, et seq.

THIS EXECUTIVE ORDER DOES NOT CONSTITUTE A CERTIFICATION,
ACCREDITATION, APPROVAL, OR ANY OTHER TYPE OF ENDORSEMENT BY THE
AIR RESOURCES BOARD OF ANY CLAIMS OF THE APPLICANT CONCERNING
ANTI—POLLUTION BENEFITS OR ANY ALLEGED BENEFITS OF THE HONDATA
FLASHPRO.

Violation of any of the above conditions shall be grounds for revocation of this Executive
Order. The Executive Order may be revoked only after a ten—day written notice of
intention to revoke the Executive Order, in which period the holder of the Executive
Order may request in writing a hearing to contest the proposed revocation. If a hearing
is requested, it shall be held within ten days of receipt of the request, and the Executive
Order may not be revoked until a determination is made after a hearing that grounds for
revocation exist.

Executed at El Monte, California, this     lj      day of April 2017.



                 Annette Hebert, Chief
                 Emissions Compliance, Automotive Regulations and Science Division




                          HONDATA— FLASHPRO — D—742—1


>



Document Created: 2017-07-18 08:38:59
Document Modified: 2017-07-18 08:38:59

Previous E.O. D-742 | Previous E.O. D-741 | Next E.O. D-742-2 | Next E.O. D-743