Approval Details

Valid E.O.

Validity

This Executive Order approved the specified parts on on March 17, 2004.
As of Tuesday, December 11th, 2018 this Executive Order has not been overturned or superceeded.

Approved Parts

Part NumberModels
1618Ford 1989-1999 Pasesnger Car 3.8L

This Executive Order may be listed as:
  • C.A.R.B.E.O. D-216-27
  • Executive Order 216-27 / D216-27
  • ARB # D-216-27
  • Executive Order No: D-216-27
  • C.A.R.B. No. D-216-27
  • Resolution D-216-27
For Free CARB Executive Order Status verification, email an image of the device Executive Order label as well as the Year/Make/Model and Test Group # of the vehicle to [email protected]

Download: Executive Order D-216-27 PDF

D-216-27 Document:



                                       State of California
                                   AIR RESOURCES BOARD

                                 EXECUTIVE ORDER D—216—27

                          Relating to Exemptions Under Section 27156
                                       of the Vehicle Code

                                Automotive Engineered Products
                                         JBA Headers


Pursuant to the authority vested in the Air Resources Board by Section 27156 of the Vehicle
Code; and

Pursuant to the authority vested in the undersigned by Section 39515 and Section 39516 of the
Health and Safety Code and Executive Order G—02—003;

IT IS ORDERED AND RESOLVED: That the installation of the JBA Headers, manufactured and
marketed by Automotive Engineered Products, Inc., 7149 Mission Gorge Road, San Diego,
California, 92120 has been found not to reduce the effectiveness of the applicable vehicle
pollution control system and, therefore, is exempt from the prohibitions of Section 27156 of the
Vehicle Code for those applicable gasoline powered General Motors and Ford vehicles listed in
 Exhibit A of this Executive Order. Vehicles under the following test groups are emissions
 certified to the Ultra—Low Emissions Vehicle (ULEV) emission standards and/or the
 Supplemental Federal Test Procedure (SFTP) standards, and are excluded from this
 Executive Order: Ford, 2001model—year, 1FMXHO6.8TH5, 1FMXHOS5.4THS5, 1FMXVO4.6VF5,
 1FMXVO4.6VF7, 1FMXTO3.82J5, 1FMXTO3.82J6, and 1FMXT03.01F6, Ford, 2002 model—
year, 2FMXHO6.8TH5, 2FMXTO04.62F5, 2FMXT04.62F6, 2FMXT04.22H5, 2FMXTO04.22H6,
 2FMXTO04.02F7, 2FMXTO4.02F8, 2FMXTO03.82J7, 2FMXT03.01F6, and 2FMXTO03.01F7,
 General Motors, 2000 model—year, YGMXVO3.8901 and YGMXVO3.8044, General Motors,
 2001 model—year, 1GMXVO5.7081, 1GMXA05.3185, 1GMXTO4.3187, and 1GMXVO3.8044,
General Motors, 2002 model—year, 2GMXAO05.3185, 2GMXTAO0S5.3186, and 2GMXAO04.3189.

The JBA Headers are a shorty style header, manufactured out of either 16 gage stainless steel
or 14 gage mild steel. The headers bolt to the stock connecting pipes and retain the oxygen
sensor in its stock location.

This Executive Order is valid provided that the installation instructions for the headers will not
recommend tuning the vehicle to specifications different.from those of the vehicle manufacturer.

Changes made to the design or operating conditions of the headers, as exempt by the Air
Resources Board, which adversely affect the performance of the vehicle‘s pollution control
system shall invalidate this Executive Order.
                                      #*
This Executive Order shall not applyto any Automotive Engineered Products, Inc.‘s JBA
Headers advertised, offered for sale, sold with, or installed on a new motor vehicle prior to or
concurrent with transfer to an ultimate purchaser.


                                                2.

Marketing of the headers using any identification other than that shown in this Executive Order
or marketing of the headers for an application other than those listed in this Executive Order
shall be prohibited unless prior approval is obtained from the Air Resources Board. Exemption
of the headers shall not be construed as exemption to sell, offer for sale, or advertise any
component of the kit as an individual device.

This Executive Order does not constitute any opinion as to the effect the use of the headers
may have on any warranty either expressed or implied by the vehicle manufacturer.

This Executive Order is granted based on a prior evaluation which determined that Automotive
Engineered Products, Inc.‘s JBA Headers does not cause an adverse effect on emissions of
selected vehicles (Executive Order D—216—26), and does not affect the vehicle‘s ability to
perform its On—Board Diagnostic II (OBD II) system monitoring. The same effect on emissions
and OBD II system monitoring is expected fromthe use of the JBA Headers on vehicles listed in
this Executive Order.

THIS EXECUTIVE ORDER DOES NOT CONSTITUTE A CERTIFICATION, ACCREDITATION,
APPROVAL, OR ANY OTHER TYPE OF ENDORSEMENT BY THE AIR RESOURCES BOARD
OF ANY CLAIMS OF THE APPLICANT CONCERNING ANTI—POLLUTION BENEFITS OR ANY
ALLEGED BENEFITS OF AUTOMOTIVE ENGINEERED PRODUCTS, INC.‘S JBA HEADERS.

No claim of any kind, such as "Approved by the Air Resources Board", may be made with
respect to the action taken herein in any advertising or other oral or written communication.

Violation of any of the above conditions shall be grounds for revocation of this order. The order
may be revoked only after a ten—day written notice of intention to revoke the order, in which
period the holder of the order may request in writing a hearing to contest the proposed
revocation. If a hearing is requested, it shall be held within ten days of receipt of the request
and the order may not be revoked until a determination is made after the hearing that grounds
for revocation exist.

Executed at El Monte, California, this [7'7{ day of March 2004.




                                 Alle%yons, Chief _ ;
                                 Mobile Source Opeyatfgns Division




             AUTOMOTIVE ENGINEERED PRODUCTS—JBA HEADERS—D—216—27


                                                  Exhibit A
1618                  1989—1999 FORD PASSENGER CAR 3.8L
1619                  1979—1999 FORD PASSENGER CARS 3.8L.
1620,16821,1624       1979—95 FORD PASSENGER CARS 5.0L
1625                  1996—2002 FORD PASSENGER CARS 4.8L (EXCEPT 1FMXVO4.6VF5, 1FMXVO4.6VF7, 2FMXVO4.6VF5S)
1626                  1993—2002 FORD PASSENGER CARS 4.6L, (EXCEPT 1FMXVO4.6VF5, 1FMXVO4.6VFT7, 2FMXVO4.6VF5)
1627                  1966—96 FORD TRUCKS 5.0L, 1966—1986 TRUCKS 5.8L
1628                  1966—96 FORD TRUCKS 5.8L.
1629                  1988—98 FORD TRUCKS 7.5L.
1630, 1632            1986—91 FORD TRUCKS 2.91L.
1633                  1990—94 FORD TRUCKS 4.0L
1634                  1995—2002 FORD TRUCKS 4.0L (EXCEPT 2FMXT04.02F7, 2FMXTO4.02F8)
1635                  1974—87 FORD TRUCKS 429—460 CID
1639                  1979—95 FORD PASSENGER CARS 5.8L.
1645                  1989—93 FORD PASSENGER CARS 5.0L
1646                  1986—2002 FORD TRUCKS 3.0L, (EXCEPT 1FMXTO3.01F8, 2FMXTO3.01F8, 2FMXT03.01F7)
1650, 1653            1965—73 FORD PASSENGER CARS 289—351 CID                 _
1660                  1966—77 FORD TRUCKS 289—351 CID
1667                  1996 FORD TRUCKS 5.0L.
1668                  1987—99 FORD TRUCKS 5.0L, 5.8L.
1669                  1998—2002 FORD TRUCKS 10 CYL, (EXCEPT 1FMXHO6.8THS, 2FMXHOG6.8THS)
1671                  1966—96 FORD TRUCKS 6 CYL                             |
1672                  1997—2002 FORD TRUCKS 6 CYL (EXCEPT 1FMXTO03.82J5, 1FMXTO03.8246, 2FMXTO03.82)7,
                      2FMXTO04.22H5, 2FMXTO4.22H6)
1673                  2000—2002 FORD TRUCKS 8 CYL, (EXCEPT 1FMXT03.82J5, 1FMXTO3.832J6, 2FMXT03.82)7,
                      2FMXT04.22H5, 2FMXTO4.22H6)
1674                  1998—2002 FORD TRUCK 4.0L OHC (EXCEPT 2FMXTO04.02F7, 2FMXTO04.02F8)
1677                  1997—2002 FORD TRUCKS 4.6L (EXCEPT 2FMXT04.62F5, 2FMXTO4.62F6)
1679                  1997—2002 FORD TRUCKS 5.4L, (EXCEPT 1FMXHO5.4TH5, 2FMXA5.4HJD, 2FMXTO5.4RF6,
                      2FMXHO5.4TH5, 2FMXHO§.4THG)
1680, 1681            1972—2000 FORD PASSENGER CARS 4 CYL
1685, 1686            1972—2002 FORD TRUCKS 4 CYL (EXCEPT 1FMXTO3.01F6, 2FMXTO03.01F6, 2FMXT03.01F7)
1690                  2000—2002 FORD PASSENGER CAR 5.4L                     |
1692                  2000—2002 FORD PASSENGER CAR 4.61L., (EXCEPT 1FMXVO4.6VF5, 1FMXVO4.6VF7, 2FMXVO4.6VF5
GENERAL MOTORS
1801, 1802            1982—92 GM PASSENGER CARS 5.0L., 5.7L
1803                  1993—95 GM PASSENGER CARS 5.7L, 1980—91 TRUCKS 5.0L, 5.7L
1804                  1995—97 GM PASSENGER CARS 5.7L                          |
1805                  1993—01 GM PASSENGER CARS 6 CYL (EXCEPT YGMXVO3.8901, YGMXVO3.8044, 1GMXVO3.8044)
1806                  1994—96 GM PASSENGER CAR 5.71
1807, 1808            1997—2001 GM PASSENGER CAR 5.71 (EXCEPT 1GMXVO5.7081)
1810                  1984—91 GM PASSENGER CARS 5.71
1815, 1816            1992—96 GM PASSENGER CARS 5.7L, 1980—91 TRUCKS 5.0L, 5.7L
1817                  1997—2001 GM PASSENGER CAR 5.7L, (EXCEPT 1GMXVO5.7081)
1818                  1965—75 GM PASSENGER CAR 396—454 CID            a
1819                  1965—88 GM PASSENGER CAR 283—400 CID         mgt=t
1822, 1823            1988—2000 GM TRUCKS 7.4L                   _
1826                  1965—1991 GM TRUCKS 7.4L
1828                  1988—1995 GM TRUCKS 7.4L
1830,1834,1835        1965—1995 GM TRUCKS/PASSENGER CAR 283—400 CID
1831                  1988—1995 GM TRUCKS 5.01/5.7L
1832                  1996—2000 GM TRUCKS 5.0L/5.7L
1840,1841,1843,1845   1988—1995 GM TRUCKS 4.3L
1842,1844,1846        1996—2002 GM TRUCKS 4.3L, (EXCEPT 1GMXT04.3187, 2GMXA04.3189)
1850,1851             1999—2002 GM TRUCKS 4.8L—6.0L., (EXCEPT 1GMXAO05.3185, 2GMXA05.3185, 2GMXTAO05.3186)
1860                  2000—2002 GM TRUCK 8.1L                                 |
1900, 1901            1985—88 BUICK REGAL T—TYPE & GRAND NATIONAL TURBO 3.8L



Document Created: 2005-09-01 12:44:19
Document Modified: 2005-09-01 12:44:19

Previous E.O. D-216-26 | Previous E.O. D-215 | Next E.O. D-216-28 | Next E.O. D-217