Approval Details

Valid E.O.

Validity

This Executive Order approved the specified parts on on April 20, 2015.
As of Tuesday, July 16th, 2019 this Executive Order has not been overturned or superceeded.

Approved Parts

Part NumberModelsModification
66005ASpecific models of 2011-2015 Harley-Davidson motorcycles.The Fuelpak FP3 reprograms the FLASH memory chip in the motorcycle's electronic control module (ECM) and is designed to increase fuel into the combustion chamber during high load conditions. Installation does not require the modification or removal of any sensor or emission control device. The Fuelpak FP3 is not designed to allow a user to modify the programming.

This Executive Order may be listed as:
  • C.A.R.B.E.O. D-632-2
  • Executive Order 632-2 / D632-2
  • ARB # D-632-2
  • Executive Order No: D-632-2
  • C.A.R.B. No. D-632-2
  • Resolution D-632-2
For Free CARB Executive Order Status verification, email an image of the device Executive Order label as well as the Year/Make/Model and Test Group # of the vehicle to [email protected]

Download: Executive Order D-632-2 PDF

D-632-2 Document:



                                   State of California
                               AIR RESOURCES BOARD

                             EXECUTIVE ORDER D-632-2

                      Relating to Exemptions Under Section 27156
                                 of the California Vehicle Code

                     V & H Performance, Inc. (dba Vance & Hines)
                                    Fuelpak FP3

Pursuant to the authority vested in the Air Resources Board by Section 27156 of the
Vehicle Code; and

Pursuant to the authority vested in the undersigned by Section 39515 and
Section 39516 of the Health and Safety Code and Executive Order G-14-012;

IT IS ORDERED AND RESOLVED : That the installation of the Fuelpak FP3, produced
and marketed by V & H Performance, Inc. (dba Vance & Hines) of 13861 Rosecrans
Avenue , Santa Fe Springs, California 90670, has been found not to reduce the
effectiveness of the applicable vehicle pollution control systems and , therefore, is
exempt from the prohibitions of Section 27156 of the Vehicle Code for 2011 through
2015 model year Harley-Davidson motorcycles listed in Exhibit A.
                         '
The Fuelpak FP3 is a programming device that is designed to work with the stock
motorcycle's electronic control unit (ECU) and sensors in a closed-loop system that
modifies the air-fuel ratio to maximize vehicle performance and efficiency.

This Executive Order is valid provided that the installation instructions for the Fuelpak
FP3 will not recommend tuning the vehicle to specifications different from those of the
original V & H Performance, Inc. application.

Changes made to the design or operating conditions of the devices, as exempted by the
Air Resources Board, which adversely affect the performance of the vehicle's pollution
control system shall invalidate this Executive Order.

Marketing of the Fuelpak FP3 using any identification other than that shown in this
Executive Order or marketing of this device for an application other than those specified
in this Executive Order shall be prohibited unless prior approval is obtained from the Air
Resources Board.

This Executive Order does not co nstitute any opinion as to the effect the use of these
devices may have on any warranty either expressed or implied by the vehicle
manufacturer.


This Executive Order is granted based on submitted emission test data from an
independent laboratory on a 2014 model year Harley-Davidson Tri Glide Ultra 1688 cc
motorcycle (engine family EHDXC1.68AEE). The results are shown below in grams per
kilometer, with multiplicative deterioration factors (df's) applied :

                                                     HC+NOx            CO

Standards (g/km)                                        0.7            12
Device (g/km) with df's applied                         0.36            1.45

Test results showed that the Fuelpak FP3 when installed on the vehicle did not cause
the exhaust emissions to exceed the applicable emission standards during the Cold
Start Federal Test Procedure.

The ARB reserves the right in the future to review this Executive Order and the
exemption provided herein to assure that the exempted add-on or modified part
continues to meet the standards and procedures of Title 13, California Code of
                                                                         1
Regulations, Section 2222, et seq.

THIS EXECUTIVE ORDER DOES NOT CONSTITUTE A CERTIFICATION ,
ACCREDITATION, ·APPROVAL, OR ANY OTHER TYPE OF ENDORSEMENT BY THE
AIR RESOURCES BOARD OF ANY CLAIMS OF THE APPLICANT CONCERNING
ANTI-POLLUTION BENEFITS OR ANY ALLEGED BENEFITS OF THE FUELPAK FP3 .

No claim of any kind, such as "Approved by the Air Resources Board" , may be made
with respect to the action taken herein in any advertising or other oral or written
communication.

Violation of any of the above conditions shall be grounds for revocation of this order.
The order may be revoked only after a ten-day written notice of intention to revoke the
order, in which period the holder of the order may request in writing a hearing to contest
the proposed revocation. If a hearing is requested, it shall be held within ten days of
receipt of the request and the order may not be revoked until a determination is made
after the hearing that grounds for revocation exist.

Executed at El Monte, California, this    2 0        day of April 2015.




                 Annette Hebert, Chief
                 Emissions Compliance, Automotive Regulations and Science Division




                    V & H PER FO RMA NC E, IN C. - FUE LPAK FP3 - D-632-2


                                         EXHIBIT A

                             VANCE & HINES FUELPAK FP3

PARTNUMBER: 66005A

MODEL      ENGINE                                          ENGINE       EMISSION
YEAR       FAMILY           MODELS                         (CC)         CONTROLS
                            CVO ROAD GLIDE ULTRA, CVO
                            STREET GLIDE, CVO ULTRA
                            LIMITED, ELECTRA GLIDE
                            ULTRA LIMITED LOW, ULTRA
   2015    FHDXC1.80AEF     LIMITED                        1802, 1688   TWC, SFI, 2H02S
                            ELECTRA GLIDE ULTRA
                            CLASSIC, ELECTRA GLIDE
                            ULTRA CLASSIC LOW,
                            FREEWHEELER, ROAD GLIDE,
                            ROAD GLIDE SPECIAL, ROAD
                            KING, STREET GLIDE, STREET
   2015    FHDXC1.80AED     GLIDE SPECIAL                  1688         TWC, SFI, 2H02S
   2015    FHDXC1.80AEE     TR1 GLIDE ULTRA                1688         TWC, SF!, 2H02S
                            BREAKOUT, CVO DELUXE, FAT
                            BOY, FAT BOY LO, HERITAGE
                            SOFTAIL CLASSIC, SOFTAIL
                            DELUXE, SOFTAIL SLIM,
   2015    FHDXC1.80AEC     STREET BOB, STREET BOB NGP     1802, 1688   2TWC, SFI, 2H02S
                            FAT BOB, LOW RIDER,
   2015    FHDXC 1.80AEB    SWITCHBACK, WIDE GLIDE         1688         TWC, SFI, 2H02S
                            1200 CUSTOM, 1200 CUSTOM(C),
                            FORTY EIGHT, SEVENTY-TWO,
   20 15   FHDXCO 1.2CEA    SUPERLOW 1200T                 1200         2TWC, SFI, 2H02S
   2015    FHDXC0.88CEA     IRON 883, SUPERLOW             883          2TWC, SFI, 2H02S
   2015    FHDXC0.50AXG     STREET 500                     494          SFI, 2H02S
   2015    FHDXC0.75AXG     STREET 750                     749          TWC, SFI, 2H02S
                            CVO ULTRA LIMITED, ULTRA
   20 14   EHDXC 1. 80AEF   LIMITED                        1802, 1688   TWC, SF!, 2H02S
                            CVO ROAD KING, ELECTRA
                            GLIDE ULTRA CLASSIC, ROAD
   2014    EHDXC1.80AED     KING, STREET GLIDE             1802, 1688   TWC, SFI, 2H02S
   2014    EHDXC 1.68AEE    TRI GLIDE ULTRA                1688         TWC, SF!, 2H02S
                            BREAKOUT, CVO BREAKOUT,
                            CVO DELUXE, FAT BOY, FAT
                            BOY LO, HERITAGE SOFTAIL
                            CLASSIC, SOFTAIL DELUXE,
                            SOFTAIL SLIM, STREET BOB,
   20 14   EHDXC1.80AEC     SUPER GLIDE CUSTOM             1802, 1688   2TWC, SFI, 2H02S
                            FAT BOB, SWITCHBACK, WIDE
   2014    EHDXC1.80AEB     GLIDE                          1688         TWC, SFI, 2H02S
                            1200 CUSTOM, FORTY-EIGHT,
   2014    EHDXC01.2CEA     SEVENTY-TWO                    1200         2TWC, SF!, 2H02S

   2014    EHDXC0.88CEA     IRON 883, SUPERLOW             883          2TWC, SF!, 2H02S
                            BLACKLINE, FAT BOY, FAT
                            BOY LO, HERITAGE SOFT AIL
   20 13   DHDXC1.80AEC     CLASSIC, SOFTAIL BREAKOUT,     1688, 1584   2TWC, SFI, 2H02S


                                  EXHIBIT A

                         VANCE & HINES FUELPAK FP3

                        SOFTAIL DELUXE, SOFT AIL
                        SLIM, STREET BOB, SUPER
                        GLIDE CUSTOM
                        FAT BOB, SWITCHB ACK, WIDE
20 13   DHDXC1.80AEB    GLIDE                         1688         TWC, SFI, 2H02S
                        BLACKLINE, FAT BOY, FAT
                        BOY LOW, HERITAGE CLASSIC,
                        SOFTAIL DELUXE, STREET BOB,
2012    CHDXC 1.80AEC   SUPER GLIDE CUSTOM            1688, 1584   2TWC, SF!, 2 H02S
                        FAT BOB, SWITCHBACK, WIDE
20 12   CHDXC 1.80AEB   GLIDE                         1688         TWC, SF!, 2H02S
                        BLACKLINE, FAT BOY LO, FAT
                        BOY, HERITAGE SOFTAIL
                        CLASS IC, SOFTAIL DELUXE,
2011    BHDXC1.80AEC    CROSS BONES, ROCKER C,        1688, 1584   2TWC, SF!, 202S



Document Created: 2015-05-11 15:59:18
Document Modified: 2015-05-11 15:59:18

Previous E.O. D-632-1 | Previous E.O. D-631 | Next E.O. D-632-3 | Next E.O. D-633