Approval Details

Valid E.O.

Validity

This Executive Order approved the specified parts on on April 22, 2008.
As of Thursday, December 26th, 2024 this Executive Order has not been overturned or superceeded.

Approved Parts

Part NumberModelsRemarks
61001G, 61003G, 61005G, 61007G, 2007 and 2008 Harley Davidson MotorcyclesThe Fuelpak EX is an electronic control module (ECM) that works with the stock motorcycleÔÇÖs ECM and is designed to increase fuel into the combustion chamber during high load conditions. The Fuelpak is installed in series to the stock wiring harness of the ECM and allows the user of the motorcycle to input a code designed to increase or decrease the amount of fuel going into the combustion chamber. Ignition timing is not modified. The code is selected based on other legal modifications made to the motorcycle (e.g. air cleaner or exhaust system). Installation does not require the modification or removal of any sensor or emission control device. The Fuelpak is not designed to allow a user to download or modify the programming.

This Executive Order may be listed as:
  • C.A.R.B.E.O. D-632-1
  • Executive Order 632-1 / D632-1
  • ARB # D-632-1
  • Executive Order No: D-632-1
  • C.A.R.B. No. D-632-1
  • Resolution D-632-1
For Free CARB Executive Order Status verification, email an image of the device Executive Order label as well as the Year/Make/Model and Test Group # of the vehicle to [email protected]

Download: Executive Order D-632-1 PDF

D-632-1 Document:

CARB_D-632-1

State of California AIR RESOURCES BOARD EXECUTIVE ORDER D-632-1 Relating to Exemptions Under Section 27156 of the California Vehicle Code V & H Performance, Inc. (dba Vance & Hines) Fuelpak EX Pursuant to the authority vested in the Air Resources Board by Section 271 56 of the Vehicle Code; and Pursuant to the authority vested in the undersigned by Section 39515 and Section 39516 of the Health and Safety Code and Executive Order G-02-003; IT IS ORDERED AND RESOLVED: That the installation of the Fuelpak EX, produced and marketed by V & H Performance, Inc. (dba Vance & Hines) of 13861 Rosecrans Avenue, Santa Fe Springs, California 90670, has been found not to reduce the effectiveness of the applicable vel-~iclepollution control systems and, therefore, is exempt from the prohibitions of Section 27156 of the Vehicle Code for the following 2007 and 2008 model year Harley Davidson motorcycle applications. Part No. Application 61001G Softail 2007 FLSTN, FLSTC, FLSTSC, FXSTD, 2008 FLSTN, FLSTC 61003G Touring 2007 FLHR, FLHRS, FLHRC, FLHX, FL-TR, FLHT, FLHTC, FLHTCU 61005G Dyna 2007 FXD, FXDC, FXDB, FXDL, FXDWG, 2008 FXD, FXDC, FXDB, FXDL, FXDWG, FXDF VRSC 2007 VRSCAW, VRSCD, VRSCDX, VRSCX, VRSCR, 2008 VRSCAW, VRSCD, VRSCDX 61007G Sportster 2007 XL883, XL883L, XL883C, XL883R, XL883N, XL1200N, XL1200C, XL1200R, XL1200L, 2008 XL883, XL883L, XL883C, XL1200N, XL1200L, XL1200C, XL1200R Softail 2007 FXST, FXSTB, FXSTC, FLS-TF, 2008 FXST, FXS-TB, FXSTC, FLSTF 61009G Touring 2008 FLHR, FLHRC, FLHX, FLTR, FLHT, FLHTC, FLHTCU 6101 1G Softail 2008 FXCW, FXCWC The Fuelpak EX is an electronic control module (ECM) that works with the stock motorcycle's ECM and is designed to increase fuel into the combustion chamber during high load conditions. This Executive Order is valid provided the installation instructions for the Fuelpak EX will not recommend ,tuning the motorcycle to specifications different from those of tlie V & H Performance, Inc. Changes made to the design or operating conditions of the Fuelpak EX, as exempt by the Air Resources Board, which adversely affect the performance of the vehicle's pollution control system shall invalidate this Executive Order.

Marketing of the Fuelpak EX using any identification other than that shown in this Executive Order or marketing of the Fuelpak EX for an application other than those listed in this Executive Order shall be prohibited unless prior approval is obtained from the Air Resources Board. This Executive Order does not constitute any opinion as to the effect the use of the Fuelpak EX may have on any warranty either expressed or implied by the vehicle manufacturer. This Executive Order is granted based on submitted emission test data generated on two motorcycles. Test results showed that emission levels, with the Fuelpak EX installed and programmed, met the applicable emission standards when tested using the Cold-Start CVS-75 Federal Test Procedure (FTP). Results from emission testing conducted at Ecologic Testing Laboratory, located in Fullerton, California, are shown below in grams per kilometer with deterioration factors applied. I 2007 Harley 2008 Harley Davidson 1.5L Davidson 1.6L Touring Touring HC+NOx CO HC+NOx CO Stds. 1.2 12 Stds. 0.6 12 Device wl dfs 1.2 7 Device wldfs 0.5 2 Similar effect on motorcycle emissions is expected with the installation of the Fuelpak EX on motorcycles listed in this Executive Order. The Air Resources Board reserves the right in the future to review this Executive Order and the exemption provided herein to assure that the exempted add-on or modified part continues to meet the standards and procedures of Title 13, California Code of Regulations, Section 2222, et seq. THIS EXECUTIVE ORDER DOES NOT CONSTITUTE A CER-TIFICATION, ACCREDITATION, APPROVAL, OR ANY OTHER TYPE OF ENDORSEMENT BY THE AIR RESOURCES BOARD OF ANY CLAIMS OF THE APPI-ICANT CONCERNING AN-TI-POLLU-TION BENEFITS OR ANY ALLEGED BENEFITS OF V & H PERFORMANCE, INC. 'S FUELPAK EX. No claim of any kind, such as "Approved by the Air Resources Board", may be made with respect to the action taken herein in any advertising or other oral or written commur~ication. Violation of any of the above conditions shall be grounds for revocation of this order. The order may be revoked only after a ten-day written notice of intention to revoke the order, in which period the holder of the order may request in writing a hearing to contest the proposed revocation. If a hearing is requested, it shall be held within ten days of receipt of the request and the order may not be revoked until a determination is made after the hearing that grounds for revocation exist. Executed at El Monte, California, this 22-day of April 2008. Annette Hebert, Chief Mobile Source Operations Division V & H PERFORMANCE, INC. - FUELPAK EX - D-632-1


Document Created: 2008-05-09 11:55:40
Document Modified: 2008-05-09 11:55:40

Previous E.O. D-632 | Previous E.O. D-631 | Next E.O. D-632-2 | Next E.O. D-633